为了更好的满足使用者的需求，避免因种类选择而产品的不良影响，我公司现将3种市面较常见的环氧地坪产品做出相应的分析与对比。一、环氧地坪 ：环氧地坪在混凝土密封固化剂还没有引进中国市场前已经得到了广泛的蓬勃发展。但随着时间越长，它的优点和缺点逐渐被人们所认识：只能附着于水泥表面耐磨和抗重压能力较弱，一般只能让小型车辆行驶，不能让大型车辆行驶，所以一般在地下车库或者汽车4S店使用。容易划伤和损坏，由于环氧地坪一般比较薄，在1到3mm之内，导致容易被一些刀具，锐利物品划伤（大部分环氧地坪被划伤影响不大，但只要环氧地坪被划伤最为影响美观度）。施工要求一般较高，如果在施工中没有注意空气湿度、地面湿度或地面表面油污，在上述指标未达标的情况下进行施工，则可能导致起泡起皮和脱落等现象。环氧地坪清洁容易，维护成本比较低，使用寿命一般在10年之内，但是施工条件要求高，工期稍长一点，其拥有良好的防腐防尘功能。 环氧地坪的特殊性使得其在地坪行业中起到许多地坪所不可替代作用，对于大多数的地下车库及部分医药，电子企业来说，选择环氧地坪能很好的满足其对地坪的要求。
In order to better meet the needs of users and avoid the adverse effects of products due to the selection of types, our company now makes corresponding analysis and comparison of three kinds of floor products which are more common in the market. First, epoxy flooring: epoxy flooring has been widely developed before concrete sealing and curing agent was introduced into the Chinese market. But as time goes on, its advantages and disadvantages are gradually recognized by people: it can only adhere to the cement surface with weak wear resistance and resistance to heavy pressure, generally can only allow small vehicles to drive, can not allow large vehicles to drive, so it is generally used in underground garage or 4S shop. Easily scratched and damaged, because the epoxy floor is generally thin, within 1 to 3 mm, leading to vulnerable to some cutters, sharp objects scratched (most of the floor scratched little impact, but as long as the epoxy floor is scratched the most impact on aesthetics). Construction requirements are generally higher. If air humidity, ground humidity or surface oil pollution are not paid attention to during construction, construction under the condition of the above indicators are not up to the standard may lead to foaming, peeling and other phenomena. Epoxy floor is easy to clean, low maintenance cost, and its service life is generally within 10 years, but the construction conditions are demanding, the construction period is a little longer, and it has good anti-corrosion and dust-proof function. The particularity of epoxy flooring makes it play an irreplaceable role in many flooring industries. For most underground garages and some medical and electronic enterprises, the choice of epoxy flooring can well meet their requirements for flooring. 二、金刚砂耐磨地坪 ：金刚砂耐磨地坪起步稍晚于水泥地坪，其原材料由一定颗粒级配的矿物合金骨料，特种波兰特水泥，其它各种掺合料和外加剂组成，开袋即可使用。将其均匀地撒布在初凝阶段的混凝土表面，同时经专门手段加工。从而使其与新浇混凝土地面形成一个整体，且具有比较致密性和着色的高性能耐磨地面。它的特点是：颜色可选，表面密实、不容易起尘易清洁，但相应的由于材料使用了水泥，所以造成颜色有一定的局限，使得可选颜色不太全面。而且如果使用颜填料质量较差，则可能会使得地坪褪色。可取代工业厂房传统的水磨石地坪，在整体效果上与工业传统的水磨石地坪基本相同，仅仅骨料更细致。与水泥混凝土同步施工，能快速投入使用，由于同步施工的原因，使得使用周期要比其他地坪要短很多，而且每天施工的面积可达数千平方米，使用速度极快。成本比较低，金刚砂耐磨地坪成本是所有地坪中最低廉的，而性价方便，耐磨性能、抗冲击性能和抗压性能极佳，使得金刚砂耐磨地坪在所有地坪中性价比是最高的。而且只要能正常护理，金刚砂耐磨地坪的使用寿命一般可达8~10年，如果最后对金刚砂耐磨地坪进行密封固化剂处理后，可以使得其使用寿命增加近1到2倍。对于大多数工业生产企业来说，金刚砂耐磨地坪就最优选择。
2. Diamond abrasion-resistant floor: Diamond abrasion-resistant floor started a little later than cement floor. Its raw materials consist of mineral alloy aggregate with certain particle size distribution, special Poland cement, other admixtures and additives, which can be used in open bags. It is evenly distributed on the surface of concrete at the initial stage of solidification, and is processed by special means at the same time. Thus, it can form a whole with the newly poured concrete floor, and has a compact and colored high-performance wear-resistant floor. Its characteristics are: the color is optional, the surface is dense, it is not easy to dust and clean, but the corresponding material uses cement, so the color has certain limitations, making the optional color is not comprehensive. Moreover, if the quality of pigments and fillers is poor, the floor will probably fade. It can replace the traditional terrazzo flooring of industrial plant. The overall effect of the terrazzo flooring is basically the same as that of the traditional industrial terrazzo flooring. Only the aggregate is more detailed. Synchronized construction with cement concrete can be put into use quickly. Because of synchronous construction, the use period is much shorter than other floors, and the construction area can reach thousands of square meters every day, and the use speed is very fast. The cost is relatively low, and the cost of diamond wear-resistant floor is the lowest among all floors, and the cost-effective, wear-resistant, impact-resistant and compressive properties are excellent, making the diamond wear-resistant floor the highest cost-effective in all floors. The service life of the diamond wear-resistant floor can generally reach 8 to 10 years as long as it can be nursed normally. If the diamond wear-resistant floor is treated with sealant and curing agent, its service life can be increased by nearly 1 to 2 times. For most industrial enterprises, the diamond wear resistant floor is the best choice.
3. Concrete Sealing and Curing Agent Floor: Concrete Sealing and Curing Agent Floor was first published in the United States in the 1960s, and has a history of 50 or 60 years. It has many advantages, which make it develop rapidly in capitalist countries such as the United States and Europe after its first appearance. With people's research and improvement, it has more mature technology.
The concrete sealant and curing agent floor is mainly a non-toxic chemical product with water as the carrier. Water has a strong permeability to concrete, so it will penetrate into the depth of 6-8 mm below the surface of concrete together with the concrete sealant and curing agent. It will react with concrete to make small cracks between concrete and concrete pouring. Porosity and concrete aggregate gap may be filled and consolidated during construction. However, the density and strength of concrete are greatly increased, the 6-8mm surface of the floor is solidified as a whole, the compressive resistance and wear resistance are strengthened, the dust produced by concrete itself is avoided, and bright natural light will be produced after polishing and polishing. The longer the time of use, the more natural the light perception will be. Without waxing and cleaning, only normal means, such as mop washing and broom dry sweep, can be done. For some excellent concrete sealant floors, the service life is the longest of all floors, usually used in foreign sewers, wharfs and other long-term existence, there are frequent changes. For warehouses, wharfs and other places that need long-term preservation and remain unchanged for a long time, concrete sealing and curing agent floor is a good choice.
Floor users want to have long-term planning, reasonable choice is an important link, he can help you introduce unnecessary expenditure, a high-quality floor not only has a great impact on the ground itself, but also has a great impact on high-tech machinery, good selection can make the machine electrostatic, dust and other large reduction. Less, let you get the greatest benefit with the least investment.
Floor is not only long X width = area, but also the bearing and inheritance of corporate image, which emits the spirit of the enterprise. The quality of the floor is not only a symbol of the strength of the company and the enterprise, but also a symbol of the attitude and development potential of the company and the enterprise.
标签:   环氧地坪 地坪 环氧地坪漆 环氧地坪施工 环氧地坪翻新