欢迎光临无锡盛发地坪科技有限公司官网!【环氧地坪_防静电地坪_停车场地坪_耐磨地坪】材料生产,销售和施工的高新技术企业.

    示例图片三
    网站首页 > 新闻资讯 > 新闻资讯

    耐磨耐油污砂浆型环氧地坪(机械制造、模具、注塑等车间)

    2018-10-30 08:50:33 无锡盛发地坪科技有限公司 阅读

    (一)基层处理

    (1) grass-roots treatment

    目的:清除地面表面的浮浆,提高混凝土表面的密度,使地面与环氧地坪底涂增加附着力。

    Objective: To remove the floating slurry on the surface of the ground, improve the density of the concrete surface and increase the adhesion between the ground and the epoxy floor.

    1、使用进口环氧地坪研磨机对混凝土进行预处理,去除表面浮浆、杂质、油污并提供一定的粗糙度和平整度,增强环氧涂料与混凝土之间的附着力。

    1. Use imported floor grinder to pretreat concrete, remove surface slurry, impurities, oil and provide a certain degree of roughness and flatness, enhance the adhesion between epoxy coatings and concrete.

    2、将原来地面的裂纹采用V字处理方式进行切割处理,再使用XLB-TA01环氧树脂灌浆将裂缝填平,同时使用XLB-TB01环氧树脂砂浆处理原有环氧地坪损坏比较严重的地方,并同步吸尘保证地坪表面整洁。

    2. The original ground cracks were cut by V-shaped treatment, then filled with XLB-TA01 epoxy resin grouting, while using XLB-TB01 epoxy resin mortar to deal with serious damage to the original floor, and synchronous vacuum cleaning to ensure that the surface of the floor is clean.

    3、将伸缩缝中的原有杂物祛除,并处理干净后,用XLB-AB02无溶剂型环氧树脂材料修补好,并做好标记。

    3. Remove the original impurities in the expansion joint, and after treatment, repair it with XLB-AB02 solvent-free epoxy resin material, and mark it well.

    注:新水泥地面必须平整、坚固、不起砂、高低差2㎜/2M以下,保养30天以上,含水率5%以下。

    Note: New cement floor must be smooth, solid, no sand, height difference less than 2 /2M, maintenance more than 30 days, moisture content less than 5%.

    (二)底涂施工

    (two) primer construction

    目的:封闭表面的尘土,使底涂渗透地面,加强基层混凝土做面的牢度。

    Objective: to seal the surface dust and infiltrate the base coat to the ground to enhance the surface fastness of the base concrete.

    1、底涂施工前先进行曲地面含水率测定:以水分计测定,5%以下即可底涂涂装。亦可用一块适当大的吸水纸铺在地面上,四周用胶带贴好,使吸水纸密封,一至二天后,检查吸水点燃情况。若易燃则可以进行涂装底漆,断续可燃则含水率偏高,需用潮湿底漆或做断水处理。难燃则含水率太高,地面应再保养,不宜施工或根据地面情况确定。

    1. Measure the moisture content of curved ground before primer construction: Measure with moisture meter, primer can be applied below 5%. Also can use a suitable large piece of absorbent paper spread on the ground, around with adhesive tape, so that absorbent paper sealed, one to two days later, check the water ignition. If flammable can be coated primer, intermittent flammable high moisture content, need to use wet primer or do water cut. Refractory water content is too high, the ground should be re maintained, not suitable for construction or according to the ground conditions.

    2、 使用渗透型环氧树脂底涂XLB-AA01双组分充分搅拌混合后滚涂一遍,封闭基层。局部破损严重的地坪须多次涂刮我公司XLB-AA01及XLB-AB01,直到满渗。待底漆干透,如有凹洞的地方,使用XLB-AB02掺加石英砂混合后进行修补,局部打磨吸尘。

    2. Use penetrating epoxy resin primer XLB-AA01 two-component mixing fully agitated and rolled once, closed the base. The damaged floors must be repeatedly painted XLB-AA01 and XLB-AB01 until full penetration. When the primer is dry, if there are holes in the place, use XLB-AB02 mixed with quartz sand for repairing, local grinding and vacuum.

    注:底涂在可使用时间内滚涂或用刮片涂装,涂装时要做到薄而匀,涂布后有光泽,无光泽之处(粗糙之水泥地面)在适当时候进行补涂。

    Note: Primer should be rolled or scraped in service time. Thin and uniform, glossy and non-glossy areas (rough cement floor) should be repaired in proper time.

    (三)砂浆施工

    (three) mortar construction

    目的:根据施工要求施工砂浆层,以保证面涂表面平整,同时增强地坪硬度。

    OBJECTIVE: To construct mortar layer according to construction requirement to ensure smooth surface of surface coating and enhance hardness of floor.

    1、使用环氧树脂地坪涂料XLB-AA02掺加5-8倍级配石英砂混合后进行第一遍砂浆批刮到预期厚度,待批刮层干透, 需整体打磨吸尘。

    1. Use epoxy resin floor coating XLB-AA02 mixed with 5-8 times graded quartz sand mixing after the first batch scraping mortar to the desired thickness, the scraping layer to be dry, the need for overall grinding and vacuum.

    2、 使用环氧树脂地坪涂料XLB-AA02 掺加2-3倍级配石英石英砂混合后进行第二遍砂浆批刮。待批刮层干透,需整体打磨吸尘。

    2. Use epoxy resin floor coating XLB-AA02 mixed with 2-3 times graded quartz sand to scrape the second batch of mortar. The scraping layer must be dry and dry.

    3、 使用环氧树脂地坪涂料XLB-AA02 掺加0.5倍级配石英粉混合后进行第三遍砂浆批刮。待批刮层干透,需整体打磨。

    3. Use epoxy resin floor coating XLB-AA02 mixed with 0.5 times graded quartz powder for the third batch scraping. The scraping layer is dry and needs polishing as a whole.

    (四)中涂施工

    (four) middle coating construction

    使用环氧树脂地坪涂料XLB-AA03 掺加0.5倍级配石英粉混合后进行腻子层批刮。待批刮层干透,需整体打磨。

    The epoxy resin floor coating XLB-AA03 was mixed with 0.5 times graded quartz powder to mix the putty layer. The scraping layer is dry and needs polishing as a whole.

    注:施工时,以齿尖除去大泡,挑去粗粒杂质。若批补不平整,或者过于光滑,则需全面砂磨,以吸尘器吸干净。

    Note: during construction, remove bullae from tooth tip and pick coarse particles. If the batches are not smooth or smooth, they need to be completely sanded and cleaned by vacuum cleaner.

    (五)面涂施工

    (five) surface coating construction

    1、先使用环氧地坪涂料XLB-AA03双组分充分搅拌混合后,用短毛滚筒(不脱毛)进行涂布。

    1. Use epoxy floor coating XLB-AA03 two-component full mixing after mixing, with short wool roller (no hair off) coating.

    2、再使用环氧地坪涂料XLB-AA03双组分充分搅拌混合后,用短毛滚筒(不脱毛)进行涂布面涂。

    2. The epoxy floor coatings XLB-AA03 are fully mixed by stirring, and then coated with short wool roller (without depilation).

    注:施工时如发现砂粒杂质立即除去,搅拌桶涂料若呈硬化状态时,必须停止使用并随时更换搅拌桶。

    Note: If sand impurities are found to be removed immediately during construction and the paint of mixing drum is in a hardening state, the mixing drum must be stopped and replaced at any time.

    (六)保养:

    (six) maintenance:

    面漆施工完毕48小时后涂装保护剂,一周内不可用水、油、碱、酸等化学物涂粘。地坪保养4天后正常使用。

    Topcoat 48 hours after the completion of the application of protective agent, a week can not be water, oil, alkali, acid and other chemicals coating. Floor maintenance is normal after 4 days.

    (七)备注:

    (seven) remarks:

    本地坪特点:无尘﹑高耐磨﹑高硬化﹑耐冲击、耐重载、耐油污、无裂缝、表面平整、亮丽,使用寿命8-10年以上。无臭﹑无害,属绿色环保产品认证。

    Local characteristics: dust-free, high wear resistance, high hardening, impact resistance, heavy load resistance, oil stain resistance, no cracks, smooth and bright surface, service life of more than 8-10 years. Odorless, harmless, is a green environmental protection product certification. 



    标签:   环氧地坪 地坪 环氧地坪漆 环氧地坪施工
    无锡环氧地坪 技术支持:【易商科技】