欢迎光临无锡盛发地坪科技有限公司官网!【环氧地坪_防静电地坪_停车场地坪_耐磨地坪】材料生产,销售和施工的高新技术企业.

    示例图片三
    网站首页 > 新闻资讯 > 环氧地坪

    下雨天环氧地坪漆该如何施工?【施工技巧】

    2018-10-30 07:26:10 无锡盛发地坪科技有限公司 阅读

    随着频繁下雨的天气的到来,环氧地坪施工又遇到了一个新的问题。业内人士都知道环氧地坪漆的施工往往受到天气温度的影响。雨天,气温过高或过低都会对环氧地坪漆的施工有所影响,空气中的湿度较大,使得环氧地坪漆的施工也出现了问题,例如发白、气泡、起皱等,在这样的天气里施工环氧地坪漆,需要注意很多事项。

    With the advent of frequent rainy weather, the construction of epoxy floor has encountered a new problem. Everyone in the industry knows that the construction of epoxy floor paint is often affected by the weather temperature. Rainy days, the temperature is too high or too low will have an impact on the construction of floor paint, the humidity in the air is relatively high, making the construction of epoxy floor paint also appeared problems, such as whitening, bubble, wrinkle, etc., in such weather construction of epoxy floor paint, need to pay attention to a lot of matters. 如果因为阴雨天气地面无法正常干燥,可以使用机械烘干。环氧地坪漆最适宜的施工天气是有适当风力,气温在20°C左右。环氧地坪需要施工2~3道工序,我们必须保证每一道工序材料都完全干燥才能进行下一步工序。

    If the ground can not dry normally in rainy weather, mechanical drying can be used. The most suitable construction weather for epoxy floor paint is proper wind force and the temperature is about 20 degrees C. Epoxy floor requires two or three processes, and we must ensure that each process material is completely dry before the next process.

    下雨天气,气压普遍偏低,这时候施工环氧地坪漆就容易残留很多有害物质,且这些物质不易挥发。所以建议将施工场地的门窗打开,做好室内通风工作,这样不仅可以加快室内空气的流动性,也能保障施工人员的身体健康。下雨天气施工环氧环氧地坪漆要做好周围的防护措施,最底层施工需要准备工业专用的除湿器。

    In rainy weather, atmospheric pressure is generally low, at this time the construction of epoxy floor paint is easy to residual a lot of harmful substances, and these substances are not easy to volatilize. Therefore, it is suggested to open the doors and windows of the construction site and do a good job of indoor ventilation, which can not only speed up the fluidity of indoor air, but also protect the health of the construction personnel. Epoxy floor paint in rainy weather construction to do a good job around the protective measures, the bottom construction needs to be prepared for industrial dehumidifier.

    如果空气比较潮湿,地面也会受到影响,如果在这样潮湿的地面直接施工环氧地坪漆容易造成地坪起翘,所以施工前一定要保证地面的干燥,干湿接壤的地方可以使用隔断处理的方法。

    If the air is humid, the ground will also be affected, if in such a humid ground direct application of epoxy floor paint easy to cause the floor to warp, so before the construction must ensure that the ground is dry, wet and dry areas can use the method of partition.

    雨天施工,环氧地坪漆容易发白。这种天气,墙面和地面都会存在水汽,上材料也不容易干燥,如果腻子还没有干透就进行下一步施工就会出现一系列涂膜弊病甚至开裂。所以要保证每一道工序材料完全干燥之后再进行下一层。或者在材料中加入适量的白化水调和剂也可以加速涂料的干燥。

    On rainy days, epoxy floor paint is whitish. In this weather, there will be water vapor on the wall and the ground, the material is not easy to dry, if the putty has not dried through the next step of construction will appear a series of film defects and even cracks. Therefore, we must ensure that every process material is completely dry before proceeding to the next level. Or adding proper amount of albino water to the material can also accelerate the drying of the paint.

    空气中的含水率即湿度,可以用湿度计测量,一般环氧地坪漆施工时最好湿度在85%以下。阴雨天湿度大,容易影响涂层的固化,同时水雾在环氧地坪表面易产生发白现象,从而影响其使用效果!

    Moisture content in the air, that is, humidity, can be measured with a hygrometer, general epoxy floor paint construction, the best humidity is below 85%. High humidity in cloudy and rainy days, easy to affect the solidification of the coating, while the water mist on the surface of the epoxy floor is prone to whitening phenomenon, thus affecting its use effect!

    其次,阴雨天气气温较低,双组份环氧地坪由于要进行必要的配比才能使用,这样一来很容易造成主剂和固化剂混合不充分的情况,从而降低地坪的施工质量。

    Secondly, because of the low temperature in cloudy and rainy weather, the two-component epoxy floors can not be used until necessary mixing ratio is carried out, so it is easy to cause insufficient mixing of main agent and curing agent, thus reducing the construction quality of the floors.

    阴雨天气由于空气湿度较大、地面干燥不充分,而且环氧地坪由于其特殊的成份不能像水泥混凝土那样能和水很好的融合。所以,在我们感觉地面水份含量不大的情况下其往往还达不到施工条件,这样一来盲目施工便会造成之后的地面脱层、气泡能问题。

    Rainy weather due to the humidity of the air, the ground is not dry enough, and epoxy floor because of its special composition can not be as good as cement concrete and water fusion. Therefore, when we feel that the surface moisture content is not very large, it often can not reach the construction conditions, so that blindly construction will cause delamination of the ground after, bubble energy problems.



    标签:   环氧地坪 地坪 环氧地坪漆 环氧地坪施工
    无锡环氧地坪 技术支持:【易商科技】