欢迎光临无锡盛发地坪科技有限公司官网!【环氧地坪_防静电地坪_停车场地坪_耐磨地坪】材料生产,销售和施工的高新技术企业.

    示例图片三
    网站首页 > 新闻资讯 > 常见问题

    环氧地坪漆固化对于温度的有哪些要求?

    2018-10-29 08:28:30 无锡盛发地坪科技有限公司 阅读

    环氧地坪漆施工中,对环氧地坪施工的温度、湿度都有一定的条件要求。那么环氧地坪漆固化对于温度的有哪些要求?下面我们就这个问题做下探讨。引发环氧地坪漆固化不良主要有两个原因:一、环氧地坪漆施工中温度过底,使得漆料料反应不完全;二、固化剂的配比比例不正确。但对于专业的环氧地坪漆施工企业来讲,第二个可能性几乎不在考虑之中,比如鸿伟达环氧地坪公司来讲,我们拥有专业化的施工队伍,而且对于每项工程都会制定严格的施工方案,所以不会出现此类配比比率不对的问题。而环氧地坪漆固化受到温度的影响最大。

    In the construction of epoxy floor paint, there are certain requirements for the temperature and humidity of the floor construction. What are the requirements for the temperature of epoxy floor paint curing? Next we will discuss this problem. There are two main reasons for poor curing of epoxy floor paint: first, the temperature of the epoxy floor paint is too low during the construction, which makes the paint reaction incomplete; second, the proportion of curing agent is not correct. But for professional epoxy floor paint construction enterprises, the second possibility is hardly considered, such as Hongweida Epoxy Floor Company, we have a professional construction team, and for each project will formulate a strict construction program, so there will not be such a proportion of the problem is not right. The curing of epoxy floor paint is most affected by temperature. 

    环氧地坪漆固化的适宜温度在15-25℃之间,在不同的季节因其气温不同,固化的时间也不尽相同。而当环氧环氧地坪漆在温度降低到10℃左在,环氧地坪漆固化的速度明显变缓慢,一般在温度是不进行施工的,而在气温达到5℃以下是禁止进行环氧地坪漆施工的。因为如若在现场加入溶剂,因溶剂带走一部分热量而冷却涂膜,使得环氧地坪漆固化速度明显更慢。特别对于冬季的北方地区,对于环氧地坪漆的施工更要注意温度的影响。因其温度过底会造成不固化的情况。因此在进行环氧地坪漆工程施工时,严格加强施工管理,但当在低温下必须要进行的环氧地坪漆施时,必须环氧地坪漆施工环境采取加温措施,提高施工环境温度,只有在符合该要求的环境下施工,才能使环氧地坪漆施工达到最好的效果。

    The suitable curing temperature of epoxy floor paint is between 15 and 25 degrees C, and the curing time varies with the temperature in different seasons. However, when the temperature of epoxy floor paint is lowered to 10 C left, the curing speed of epoxy floor paint becomes slower obviously. Generally, it is not applied at temperature, but it is forbidden to use epoxy floor paint below 5 C. If a solvent is added to the field, the curing rate of the epoxy floor paint is obviously slower because the solvent takes away part of the heat and cools the film. Especially for the northern part of winter, more attention should be paid to the effect of temperature on the construction of epoxy floor paint. Because of the temperature over the bottom will cause no curing. Therefore, in the construction of the epoxy floor paint project, strict construction management should be strengthened, but when the epoxy floor paint must be applied at low temperature, heating measures must be taken to improve the construction environment temperature. Only in the environment that meets the requirements, can the epoxy floor paint be used to achieve the construction. The best result.


    标签:   环氧地坪 地坪 环氧地坪漆 环氧地坪施工
    无锡环氧地坪 技术支持:【易商科技】