欢迎光临无锡盛发地坪科技有限公司官网!【环氧地坪_防静电地坪_停车场地坪_耐磨地坪】材料生产,销售和施工的高新技术企业.

    示例图片三
    网站首页 > 新闻资讯 > 环氧地坪

    厂家揭示环氧地坪施工哪种方法最好

    2018-10-27 08:39:44 无锡盛发地坪科技有限公司 阅读

    环氧地坪施工的最好方法是高压无气喷涂!高压无气喷涂的原理是:经过一增压泵(通常为柱塞泵),使涂料增压高达210KG/CM2乃至更高,取得高压的涂料经过高压管到特别的高压枪,并从特别的喷嘴开释压力并到达涣散雾化的意图,高速地涂在被涂物上。因为涂料雾化不需压缩空气,所以称之为无空气喷涂。这种喷涂技能至1952年创造以来,得到较为广泛的运用,如轿车、飞机、工程机械、火车、轮船、集装箱等范畴。

    The best way to construct epoxy floor is high pressure airless spraying. The principle of high-pressure airless spraying is: through a booster pump (usually a plunger pump), the coating can be pressurized up to 210 KG/CM2 or higher, and the high-pressure coating can be obtained by passing through a high-pressure pipe to a special high-pressure gun, releasing pressure from a special nozzle and reaching the intent of dispersing atomization, and then spraying on the coating at high speed. Because spray atomization does not require compressed air, it is called air free spraying. Since its creation in 1952, this spraying technique has been widely used, such as cars, aircraft, construction machinery, trains, ships, containers and so on.

    环氧地坪施工哪种方法最好

    Which method is best for epoxy floor construction?

    跟着修建涂料的不断发展,高压无气喷涂技能逐步运用于修建行业,如乳胶漆、油性漆、水性漆、环氧地坪涂料、防火涂料、防水涂料等的喷涂,并逐步在国内外得到遍及。其长处主要有如下:

    With the continuous development of building coatings, high-pressure airless spraying technology is gradually applied to the construction industry, such as latex paint, paint, water-based paint, floor coatings, fire-retardant coatings, waterproof coatings and other spraying, and gradually spread at home and abroad. The main advantages are as follows:

    1、极佳的表面质量。喷涂在墙面的涂料构成平顺、细密的涂层,绝无刷痕,这是刷、滚无法比拟的。

    1. Excellent surface quality. Spraying paint on the wall constitutes a smooth, fine coating, no brush marks, this is brush, roll incomparable.

    2、涂装功率高。单人操作喷涂功率高达300~500平方米/小时,是人工刷涂的10~15倍。

    2. High power of coating. The spraying power of single person operation is as high as 300-500 square meters per hour, which is 10-15 times that of manual brushing.

    3、推迟涂层的寿数。高压无气喷涂,它选用高压喷发雾化,使漆粒取得有力动能深化喷涂面孔隙,使漆膜与喷涂面构成机械咬合,增强涂层附着力,延伸寿数。

    3, postpone the coating life. High-pressure airless spraying, it uses high-pressure spraying atomization, so that the paint particles have strong kinetic energy to deepen the surface pores, so that the film and the spraying surface constitute a mechanical occlusion, enhance the adhesion of the coating, extend the life.

    4、刷涂、滚涂厚度极不均匀,通常为30~200微米之间,利用率低。而无气喷涂涂层厚度均匀,厚度在30微米摆布,利用率高。

    4, brush and roll coating thickness is very uneven, usually between 30~200 microns, low utilization rate. The airless sprayed coating has uniform thickness, thickness of 30 microns, and high utilization rate.

    5、角落和空隙也能极好地上漆。因涂料喷雾不含空气,涂料易到达这些部位。

    5, corners and gaps can also be painted very well. Because paint spray does not contain air, paints are easy to reach these parts.

    6、能简单处理高粘度涂料、稀释剂用量小,减少了对环境和大气的污染。该商品是中到大型住所、中型商务喷涂和中型维护的抱负东西。功率最高,最微弱的电机,轻松满意最恶劣的工作需要!适用涂料: 着色器、腊克漆、瓷漆、多色漆、重油性漆、乳胶漆、环氧地坪。并具有以下特征:无极调速,初次完成全调速;无炭刷,行业界初次完成直流无炭刷电机;超低温工作,永久不必忧虑电机过热;高低压主动维护,无需运用稳压器;防卡死规划,无需为任何意外情况忧虑。

    6, simple treatment of high viscosity paint, diluent consumption is small, reducing the pollution of the environment and atmosphere. The product is an ambitious thing from medium to large housing, medium business and medium maintenance. The motor with the highest power and the weakest motor is easily satisfied with the worst working needs. Applicable paint: colorer, lacquer, enamel paint, multi-color paint, heavy paint, latex paint, epoxy floor. And has the following characteristics: infinite speed regulation, the first complete full speed regulation; no carbon brush, the industry for the first time completed the DC brushless motor; ultra-low temperature work, never worry about motor overheating; high and low voltage active maintenance, no use of regulators; anti-jamming planning, no need to worry about any unexpected situation. 


    标签:  环氧地坪 行业大品牌施工 环氧地坪施工 环氧地坪漆
    无锡环氧地坪 技术支持:【易商科技】