欢迎光临无锡盛发地坪科技有限公司官网!【环氧地坪_防静电地坪_停车场地坪_耐磨地坪】材料生产,销售和施工的高新技术企业.

    示例图片三
    网站首页 > 新闻资讯 > 环氧地坪

    环氧地坪漆硬化不彻底的原因及如何预防处理

    2018-10-22 07:34:21 无锡盛发地坪科技有限公司 阅读

    环氧地坪漆硬化不彻底有哪些处理方法?:1、环氧树脂地坪硬化不彻是什么情况?①混合配比不正确,主剂含量过多或未加硬化剂②搅拌混合搅拌不均匀,主剂含量过多的地方就会有硬化不完全的现象③硬化剂有误④温度过低或湿度过高,未完全反应。

    What are the treatment methods of epoxy floor paint hardening? 1. What is the hardening of epoxy floor? (1) incorrect mixing ratio, too much main agent or without hardening agent; (2) stirring and stirring unevenly, where the main agent content is too much, there will be a phenomenon of incomplete hardening; (3) the hardening agent is wrong; (4) too low temperature or too high humidity, incomplete reaction.

    2、预防方法:

    2, prevention:

    ①必须依照主剂硬化剂混合比准备材料,施工时必须搅拌均匀。

    The material must be prepared according to the mixing ratio of the main hardener.

    ②搅拌应确实按照标准施工程序进行

    Mixing should be carried out according to the standard construction procedure.

    ③涂料一般不须再稀释。非酌加溶剂不可时,咨询本公司技术人员

    Paint should not be diluted any more. Consult the technical personnel of the company if the solvent is not available.

    ④硬化剂不能通用

    4. Hardener can not be used.

    ⑤避免低温多湿条件施工,低温下应选择低温反应的硬化剂。

    Avoid the construction of low temperature and humidity conditions, and low temperature hardening agent should be selected.

    3、处理办法:

    3, treatment:

    环氧地坪漆硬化不完全处用美工刀整齐割除

    1. The hardening of epoxy floor paint is not completely cut off with cutters.

    ②割除后将地面清理干净,用二甲苯擦拭

    After cleaning, clean the ground and wipe with xylene.

    ③修补处四周以胶带贴合

    3. Around the patch, tape is attached.

    ④底漆干燥后,以涂料填补,修补之量须略高过缺口,以免呈凹陷状

    4. When the primer is dry, fill with paint, and the amount of repair must be slightly higher than the notch so as not to be concave.

    ⑤与胶带接合处以平刮板或镘刀抹平

    (5) smoothing the adhesive tape with flat scraper or trowel.

    ⑥补后胶带立即拆除。硬化生若修补之痕迹明显,以砂纸机磨平。

    The adhesive tape should be removed immediately after repair. Hardened if the trace of repair is obvious, grind with the sandpaper machine.



    标签:   环氧地坪 地坪 环氧地坪漆 环氧地坪施工
    无锡环氧地坪 技术支持:【易商科技】