欢迎光临无锡盛发地坪科技有限公司官网!【环氧地坪_防静电地坪_停车场地坪_耐磨地坪】材料生产,销售和施工的高新技术企业.

    示例图片三
    网站首页 > 新闻资讯 > 地坪知识

    1kg环氧地坪漆的涂刷面积大致是多少平米?

    2018-10-20 08:22:33 无锡盛发地坪科技有限公司 阅读

    在与客户交流的时候,皇家环氧地坪的工作人员经常会遇到客户问的各种问题。其中,关于“一公斤环氧地坪漆可以涂刷多大面积”这类问题是最常见的。但小编发现,我们的工作人员却很少会给出一个准确的数字。小编听着各种不同的估值,实在是一头雾水。咨询了多位经验老道的施工师傅后,小编终于明白了个中缘由。原来,影响环氧地坪每平米的耗漆量的因素有很多,比如涂装的地面情况、涂装要求、施工工艺等等,包括环氧漆的底漆、中漆、面漆三种材料,每种材料每平方米用多少漆都是不一样的,所有的因素综合作用,使我们的工作人员很难给客户一个准确的数值。本着为客户负责的态度,我们的工作人员一般是在了解客户的涂装需求和基材地面情况后,根据实际可能产生的耗漆量给客户做出预估。

    When communicating with customers, the staff of the Royal floor often encounter various problems that customers ask. Among them, "one kilogram of epoxy floor paint can be painted large area" is the most common problem. But Xiaobian finds that our staff rarely give an accurate figure. Xiaobian, listening to various valuations, is really confused. After consulting many experienced masters of construction, Xiaobian finally understood why. It turns out that there are many factors affecting the amount of paint consumed per square meter on the floor, such as the ground conditions, painting requirements, construction technology, and so on, including epoxy primer, medium paint, topcoat three materials, each material per square meter with varnish is different, all the factors combined effect, so that our staff It is difficult to give the customer an accurate figure. In a customer-responsible attitude, our staff is generally in the understanding of the customer's painting needs and substrate ground conditions, according to the actual amount of paint may be produced to the customer to make estimates.

    看到这里也许您要问了,难道就没有一个可供参考的标准数值吗?

    If you want to ask here, is there not a standard reference value?

    也不是没有,据皇家地坪的李师傅说,如果是平整无缝的标准地面,市面上的环氧底漆材料一般每平方米耗费0.15kg至0.2kg,预估1kg底漆可以涂装5㎡-6㎡地面;一般环氧中漆材料使用量约为底漆的2倍,每平米要用0.4kg,1kg中漆可以刷2.5㎡;环氧面漆要涂刷两道,每道每平方用量约0.2kg,1kg面漆一般可以涂刷5㎡。但如果采用的是环氧自流平工艺,在底漆、中漆用量不变的情况下,自流平面漆材料每平方米用量就要达到0.8kg,1kg面漆一般涂刷1.2㎡左右。

    According to Li Shifu of Royal Floor, if it is flat and seamless standard floor, the general consumption of epoxy primer materials on the market is 0.15 kg to 0.2 kg per square meter, estimated that 1 kg primer can be coated 5-6 floor; the general use of epoxy medium paint materials is about twice the amount of primer, each square meter to use 0.4 kg, 1 kg Chinese paint can be used. Brush 2.5_; Epoxy topcoat to be painted two, each square dosage of about 0.2 kg, 1 kg topcoat can generally be painted 5_. However, if the epoxy self-leveling process is used, the amount of primer and mid-coat is unchanged, the amount of self-leveling surface paint material per square meter will reach 0.8 kg, 1 kg topcoat is generally brushed about 1.2 cm.

    不过,如果是皇家地坪环氧地坪漆,则用量会比市面上的更省,1kg漆料涂装面积也会更大。因为皇家地坪环氧漆的固含量要高于一般的环氧漆。所谓固含量,就是环氧地坪漆在规定条件下烘干后剩余部分占总量的质量百分数。固含量更高,漆料固化后形成的涂膜也更厚,平均下来用量更少。比如,您打算做1mm厚的环氧地坪,以上述指标计算,普通的环氧地坪漆每平方米大约需要1.3kg的用量,而皇家地坪的环氧地坪漆可以用少于1kg的漆料得到0.8mm的涂层厚度。当然,高固含量的环氧地坪漆价格比低固含量的要贵出不少,但均摊下费用更低且效果更好。

    However, if the Royal Floor Epoxy Floor Paint, then the amount of use will be more economical than the market, 1 kg paint coating area will be larger. Because the solid content of the Royal floor epoxy paint is higher than that of the ordinary epoxy paint. The so-called solid content, is the epoxy floor paint in the specified conditions after drying the remaining part of the total mass percentage. The solid content is higher, and the film formed after the curing of the paint is thicker, with less dosage on the average. For example, you're going to make an epoxy floor with a thickness of 1 mm. According to the above criteria, an ordinary epoxy floor paint needs about 1.3 kg per square meter, while an epoxy floor paint for a royal floor can get a thickness of 0.8 mm from less than 1 kg of paint. Of course, high solid content of epoxy floor paint is much more expensive than low solid content, but the cost is lower and the effect is better.

    以上所述均是在地面情况理想的前提下,在实际的施工中,每一位客户的地面或多或少都有一些问题,或起砂、起灰,或有裂缝,实际耗漆量会更大,所以皇家地坪的工作人员不会片面地说一公斤地坪漆能做多少地面,但会为了帮您省下成本,在实地勘察地面后,为您制定最实惠优质的地坪设计方案。

    The above mentioned are under the premise of ideal ground conditions, in the actual construction, each customer's ground more or less have some problems, or sand, ash, or cracks, the actual paint consumption will be greater, so the Royal floor staff will not one-sidedly say how much a kilogram of floor paint can do the ground, but will be To help you save costs, in the field survey of the ground, for you to develop the most affordable quality floor design.


    标签:   环氧地坪 环氧地坪漆 地坪 环氧地坪施工
    无锡环氧地坪 技术支持:【易商科技】