欢迎光临无锡盛发地坪科技有限公司官网!【环氧地坪_防静电地坪_停车场地坪_耐磨地坪】材料生产,销售和施工的高新技术企业.

    示例图片三
    网站首页 > 新闻资讯 > 环氧地坪

    环氧地坪日常保养的小窍门都包括哪些?

    2018-10-18 21:57:36 无锡盛发地坪科技有限公司 阅读

    环氧地坪是现在一种新型的装修材料,具有环保,节能,防腐,防潮等优点被人们所接受。我们都知道环氧地坪施工好以后会特别的脏,这个时候就需要及时的清洗,如果是清洗不干净或者是日常不重视保养,环氧地坪很快就会出现问题。所以日常清洁和保养很关键。下面就来看看环氧地坪日常保养的小窍门都包括哪些?

    Epoxy floor is a new type of decoration materials, with environmental protection, energy saving, anti-corrosion, moisture-proof and other advantages are accepted by people. We all know that the epoxy floor will be particularly dirty after construction, this time it needs timely cleaning, if it is not clean or daily care, epoxy floor will soon be a problem. Therefore, daily cleaning and maintenance are very important. Let's take a look at what are the tips for daily maintenance of epoxy floor. 

    1、环氧地坪施工完毕后需养护7-10天后方可投入使用,在养护期间,应避免水或其它溶液浸润表面、凡进入车间员工必须要换成胶底鞋(不可以穿泡沫底的黑底鞋)(以免将外面的泥沙带入车间而划伤地面)

    1. Epoxy floor should be used for 7-10 days after completion of construction. During the maintenance period, water or other solutions should be avoided to infiltrate the surface. When entering the workshop, employees must replace them with rubber soles (not wearing black shoes with foam bottom).

    2、环氧地坪使用,生产人员不准穿有铁钉的皮鞋等硬质鞋底在上面行走,防止划伤。

    2. Floor use, production personnel are not allowed to wear nailed leather shoes and other hard soles on the walk, to prevent scratches.

    3、一切工作器具都须有固定专用车架安放,严禁带有锐角的金属零件等物件碰撞地面,造成地面涂料损坏。

    3. All working appliances must be installed on a fixed special frame. It is strictly forbidden that metal parts with sharp corners collide with the ground, causing damage to the ground coating.

    4、车间内安装设备等重大物件须用起重机械时,在接触地面的支撑点应有厚橡皮等软件材料垫妥,严禁用铁管等金属在地面上接拖设备。各类推车或拖车的脚轮必须选用受力面较宽、具有一定弹性的高耐磨聚氨酯脚轮。各类推车或拖车行走时,需尽量慢速,并避免急刹车或急转弯。机器操作台的地面、较重的原材料、半成品或成品存放区地面,铺上一块橡胶垫或软质塑胶垫。。

    4. When installing equipment and other important objects in the workshop, the supporting points on the ground should be padded with thick rubber and other software materials. It is forbidden to use metal pipes and other towing equipment on the ground. The casters of all kinds of trolleys or trailers must be made of high wear-resistant polyurethane casters with wide force surface and certain elasticity. All kinds of trolleys or trailers should be as slow as possible when walking, and avoid brakes or sharp turns. Place a rubber pad or soft plastic pad on the floor of the machine operating table, heavy raw material, semi-finished product or finished product storage area.

    5、环氧环氧地坪高只能耐受80℃的温度,针对经常需要电焊或氧割的区域,应在地面上铺设钢板或其它耐高温隔离垫。车间其余区域内进行电焊等高温作业时,在电焊火花可能飞溅到的地方应用石棉布等耐火材料辅垫好,以防烧坏涂料。

    5. Epoxy floors can only withstand temperatures up to 80 C. Steel plates or other high-temperature isolation pads should be laid on the ground for areas that often require welding or oxygen cutting. When welding and other high-temperature operations are carried out in the rest of the workshop, refractories such as asbestos cloth should be used as auxiliary pads in places where sparks may spatter to prevent the coating from burning out.

    6、若因使用时间较长而造成磨损或刮花, 一旦地坪有损坏,及时使用涂料修补,小面积可进行局部修补,若面积较大则建议重新滚涂一次,,以免油污通过损坏处渗透到环氧地坪

    6. If wear or scratch occurs due to long service time, once the floor is damaged, timely use of paint to repair, small areas can be partially repaired, if the area is larger, it is recommended to roll coating again, so as to avoid oil dirt penetrating through the damage to the epoxy floor.

    7、凡是硬件:如铁椅、铁桌、铁货架等,须将其脚用软质塑料、橡胶包裹或用纸皮垫起来以免在使用过程中划伤地面、拖拉机扳需充分将机板升离地面,转弯时请特别注意机板角切勿刮伤地面。

    7. All hardware: such as iron chairs, iron tables, iron shelves, etc., must be their feet with soft plastic, rubber wrapped or padded with paper to avoid scratching the ground during use, tractor pull need to fully lift the board off the ground, turn the corner please pay special attention not to scratch the ground.


    标签:  环氧地坪 环氧地坪漆地坪 环氧地坪漆 地坪 环氧地坪养护
    无锡环氧地坪 技术支持:【易商科技】