欢迎光临无锡盛发地坪科技有限公司官网!【环氧地坪_防静电地坪_停车场地坪_耐磨地坪】材料生产,销售和施工的高新技术企业.

    示例图片三
    网站首页 > 新闻资讯 > 地坪知识

    环氧地坪漆施工的要点是什么呢?流程

    2019-08-30 10:17:31 无锡盛发地坪科技有限公司 阅读

    说到环氧地坪漆施工很多人都是知道的,而且环氧地坪漆环氧地坪性能分类,可以分为普通型环氧地坪、砂浆型环氧地坪、自流平型环氧地坪、防静电型环氧地坪及防腐型环氧地坪环氧地坪。但在进行环氧地坪漆施工时具有哪些要点呢,下面环氧地坪厂家帮大家总结一下相关的知识。

    When it comes to the construction of epoxy floor paint, many people know, and according to the performance of the floor, epoxy floor paint can be divided into ordinary epoxy floor, mortar epoxy floor, self-leveling epoxy floor, anti-static epoxy floor and anti-corrosion epoxy floor. But in the construction of epoxy floor paint, what are the key points? The following epoxy floor manufacturers help you sum up the relevant knowledge. 一、新浇筑的混凝土地面:混凝土主要是由水泥、砂、石、灰泥等组成,吸水率大、碱性强、干燥慢。新浇注混凝土的表面泛碱物和吸水率是影响涂装质量的关键,所以,在涂装前要干燥相当长的时间,除非特别减水,否则一般要求干燥28D以上,基面含水率要小于6%。表面泛碱物要彻底清除,必要时做中和处理。混凝土强度要求达到C25以上。地面平整度用2m靠尺检查,间隙不得大于3mm。

    First, the newly poured concrete ground: concrete is mainly composed of cement, sand, stone, mortar and so on. It has high water absorption, strong alkalinity and slow drying. The surface pan-alkali and water absorption of newly poured concrete are the key factors affecting the quality of coating. Therefore, it is necessary to dry for quite a long time before coating. Unless water is reduced, it is generally required to dry more than 28D and the moisture content of the base surface is less than 6%. Surface pan-alkali should be thoroughly removed and neutralized when necessary. The strength requirement of concrete is above C25. The ground roughness shall be checked by 2m ruler, and the clearance shall not be greater than 3mm.

    二、旧地面:已经使用过的旧地面,破损部位应找补。如果有蜡层、油类污染、化学腐蚀介质和旧涂层,应当采取相应方法处理。

    2. Old Ground: Old Ground that has been used should be repaired. If there are wax layer, oil pollution, chemical corrosive medium and old coating, the corresponding treatment should be taken.

    三、地坪漆要点:地坪漆中提到的自流平性能主要指面漆,底漆和中涂与其他地坪种类相同。自流平面漆是决定环氧自流平地坪表观效果和使用效果的关键。施工环氧自流平面漆,主要采取镘刀批刮的形式,通过镘刀有齿的一面轻轻带动自流平面漆,制造一点点动力,然后让自流平面漆自行流平。在施工中,温度、施工方式、施工技巧直接影响环氧自流平地坪效果。

    3. Main points of floor paint: The self-leveling performance mentioned in floor paint mainly refers to topcoat, primer and mid-coat are the same as other types of floor paint. Self-leveling surface paint is the key to determine the appearance and use effect of epoxy self-leveling floor. The construction of epoxy self-flowing surface paint mainly takes the form of batch scraping with a trowel. The self-flowing surface paint is gently driven by the toothed side of the trowel to produce a little power, and then the self-flowing surface paint is leveled by itself. In construction, temperature, construction method and construction technique directly affect the effect of epoxy self-leveling floor.


    标签:   环氧地坪 地坪 环氧地坪漆 环氧地坪施工 环氧地坪翻新
    无锡环氧地坪 技术支持:【易商科技】