欢迎光临无锡盛发地坪科技有限公司官网!【环氧地坪_防静电地坪_停车场地坪_耐磨地坪】材料生产,销售和施工的高新技术企业.

    示例图片三
    网站首页 > 新闻资讯 > 地坪知识

    去除旧的环氧地坪漆有什么更好的方法?

    2019-08-13 12:48:24 无锡盛发地坪科技有限公司 阅读

    环氧地坪从九十年代进入中国市场以来,在各行各业得到了广泛的应用。但因为环氧地坪是有寿命的,所以经过这么多年的使用,环氧旧环氧地坪翻新的工程也越来越多。针对旧的环氧地面需要分成两种情况:一种是只有小部分环氧地坪坏了,需要将松动的环氧地坪漆铲除,清理干净,然后在坏的地方重新涂布环氧树脂材料;另一种情况是环氧地坪坏得很严重,需要全部去除后,整个地面重新施工环氧地坪。 Epoxy flooring has been widely used in all walks of life since it entered the Chinese market in the 1990s. But because the epoxy floor has a life span, so after so many years of use, the renovation project of the old epoxy floor is also increasing. In view of the old epoxy floor, there are two situations: one is that only a small part of the epoxy floor is broken, the loose epoxy floor paint needs to be removed, cleaned up, and then re-coated with epoxy resin material in the bad place; the other is that the epoxy floor is badly damaged and needs to be completely removed, and the whole floor is re-coated. Construction of epoxy floor. 

    碱液去除漆法:利用碱液的腐蚀作用,使旧的环氧环氧地坪膜膨胀松软,从而达到除去旧漆的目的。采用碱涂脱漆,成本低,生产比较安全,对人体影响较小,具体步骤如下:

    Alkali Removal Paint Method: The old epoxy floor film is expanded and softened by the corrosion of alkali solution, so as to achieve the purpose of removing the old paint. Alkali paint stripping has the advantages of low cost, safe production and less impact on human body. The specific steps are as follows: 

    1,将药品逐一加入溶解,搅拌,直至均匀成糊状。

    1. Dissolve the medicine one by one and stir until it is evenly pasted. 

    2,将混合碱液脱漆剂直接用刷子涂在旧的环氧地坪漆表面,涂刷2-3遍。

    2. Paint the old epoxy floor paint directly with a brush and brush it 2-3 times. 

    3,约3小时后,旧的环氧地坪漆涂膜将被破坏,采用刮刀清除旧涂膜。

    3. After about 3 hours, the old epoxy floor paint film will be destroyed, and the old film will be removed by scraper. 

    4,清除不掉的涂膜再次涂碱液脱漆剂除去。

    4. Remove the non-removable coating and apply alkali solution paint remover again. 

    5,用温水洗净,注意多次清洗。

    5. Wash it with warm water and pay attention to it many times. 

    待地面清洗干净后,需出原来的水泥地面,等水泥地面完全干燥后,我们就可以施工新的环氧地坪了。

    After the ground is cleaned, the original cement floor is needed. After the cement floor is completely dry, we can construct a new epoxy floor. 

    操作注意事项:

    Operational precautions: 

    1,脱漆地面如果有夹层小孔,会造成碱液不易清洗,即使将旧漆脱干净,后续还会将新的环氧地坪腐蚀。所以夹层小孔区域不要采用碱液脱漆。

    1. If there are interlayer holes in the paint-stripping floor, the alkali solution will not be easy to clean. Even if the old paint is removed, the new epoxy floor will be corroded in the future. So don't use alkali to remove paint in the interlayer porous area. 

    2,工作时,戴好口罩、手套,穿好工作服,做好安全防护。

    2. Wear good masks and gloves, work clothes and safety protection when working. 

    当然,还有其它去除环氧地坪漆旧涂膜的方法:用进口的大型打磨机将旧的环氧地坪全部打磨去除,这种方法比较耗磨片,同时还会有部分粘着比较牢固的地坪漆是无法打磨掉的,所以还需要与碱液脱漆法配合使用。

    Of course, there are other ways to remove the old coating of epoxy floor paint: using imported large-scale grinder to remove all the old epoxy floor paint, this method is more abrasive, but also some of the more firmly adhered floor paint can not be polished, so it also needs to be used in conjunction with alkali depainting method. 


    标签:   环氧地坪 地坪 环氧地坪施工 无锡环氧地坪 地坪施工
    无锡环氧地坪 技术支持:【易商科技】