欢迎光临无锡盛发地坪科技有限公司官网!【环氧地坪_防静电地坪_停车场地坪_耐磨地坪】材料生产,销售和施工的高新技术企业.

    示例图片三
    网站首页 > 新闻资讯 > 地坪知识

    冬季温度太低!环氧地坪漆在低温施工注意事项

    2019-07-05 10:15:12 无锡盛发地坪科技有限公司 阅读

    环氧地坪漆是一种高强度、耐磨损、美观的地板,具有无接缝、质地坚实、耐药品性佳、防腐、防尘、保养方便、维护费用低廉等优点。环氧地坪可根据不同的用途要求设计多种方案,如薄层涂装、1-5mm厚的自流平地面、防滑耐磨涂装、砂浆型涂装、防静电、防腐蚀涂装等。环氧地坪漆涂料在低温下施工会受到一定影响,这个问题跟环氧地坪的材料息息相关。我们现在看看环氧地坪是都有些什么材料。所以环氧地坪漆涂料在低温下固化会有所限制,在冬季气温较低时会出现固化慢或者不干的现象,对于环氧地坪漆在低温下如何施工这个问题,环氧环氧地坪施工方认为,只要在材料生产中原材料、催化剂和助济的选择和使用中做些调整,是可以解决环氧环氧地坪漆在冬季低温下不固化的问题。

    Epoxy floor paint is a kind of high strength, wear-resistant, beautiful floor, with seamless, solid texture, good resistance, anti-corrosion, dust-proof, easy maintenance, low maintenance costs and other advantages. The epoxy floor can be designed according to different application requirements, such as thin coating, 1-5mm thick self-leveling floor, anti-skid and wear-resistant coating, mortar coating, anti-static, anti-corrosion coating, etc. The application of epoxy floor paint at low temperature will be affected to some extent, which is closely related to the material of epoxy floor paint. Now let's see what materials are available for epoxy flooring. Therefore, the curing of epoxy floor paint will be limited at low temperature. When the temperature is low in winter, the curing will be slow or non-drying. As for how to construct epoxy floor paint at low temperature, the epoxy floor Builder believes that as long as raw materials, catalysts and aid are selected and used in material production. Some adjustments can solve the problem that epoxy floor paint does not cure at low temperature in winter.

    环氧地坪

    冬季施工地坪漆的问题有:粘稠,施工难度加大等。但尽管冬季环氧地坪漆施工难度大,质量难保证,但如果工程确实需要在冬季或低温环境下施工,则可参考如下的办法。

    The problems of floor paint construction in winter include: stickiness, construction difficulty and so on. However, although the construction of winter epoxy floor paint is difficult and the quality is difficult to guarantee, if the project really needs to be constructed in winter or low temperature environment, the following methods can be referred to. 1、隔开低温时段

    1. Isolation of Low Temperature Period

    环氧地坪漆施工时,尽量隔开低温时段,上午10点后再开始施工,下午3点停止施工,减少低温的影响。

    During the construction of epoxy floor paint, try to isolate the low temperature period, start construction after 10 a.m. and stop construction at 3 p.m. to reduce the impact of low temperature.

    2、增加室温

    2. Increase room temperature

    增加室内温度,把温度提高到5度以上,这样也可以在冬季施工。北方很多厂房有供暖气,可在施工前和施工中开放暖气供应。

    Increase the indoor temperature, raise the temperature to more than 5 degrees, which can also be constructed in winter. Many factories in North China have heating, which can be opened before and during construction.

    3、添加溶剂

    3. Adding Solvents

    可添加小于5%的挥发速率较快的溶剂,如丙酮、醋酸乙酯、醋酸丁酯等。这样可以解决地坪漆在低温下黏度大,缺乏流平性的问题。

    Solvents with less than 5% volatilization rate can be added, such as acetone, ethyl acetate, butyl acetate, etc. This can solve the problem of high viscosity and lack of leveling of floor paint at low temperature.


    4、涂料加热

    4. Coating heating

    将涂料放置在温暖的环境,或用蒸汽、热水进行加热。但要注意不要让蒸汽或热水进入涂料内,并且热水温度控制在38度以下。

    Place the paint in a warm environment or heat it with steam or hot water. But be careful not to let steam or hot water into the paint, and the temperature of hot water should be controlled below 38 degrees.

    5、有雾天气不宜施工

    5. Foggy weather is not suitable for construction

    如果施工场地不是密封空间,遇到雾气或霜雪等气候,不能施工。如果地坪表面蒙有水汽,也不宜进行施工。

    If the construction site is not a sealed space, encounter fog or frost and snow climate, can not be constructed. If the surface of the floor is covered with water vapor, it is not suitable for construction.

    6、注意烟火

    6. Pay attention to fireworks

    冬季寒冷,工人习惯抽烟或生火取暖,这个时候一定要注意安全意识,不要再涂料堆放地附近生火或吸烟。燃放烟花等,要远离涂料堆积地,以免引发不必要的损失。

    In cold winter, workers are accustomed to smoking or lighting a fire for heating. At this time, they must pay attention to safety awareness and stop lighting a fire or smoking near the place where the paint is stacked. Fireworks, etc., should be far away from the paint accumulation site, in order to avoid causing unnecessary losses.

    环氧地坪


    标签:   地坪 环氧地坪 环氧地坪漆 环氧地坪施工
    无锡环氧地坪 技术支持:【易商科技】