欢迎光临无锡盛发地坪科技有限公司官网!【环氧地坪_防静电地坪_停车场地坪_耐磨地坪】材料生产,销售和施工的高新技术企业.

    示例图片三
    网站首页 > 新闻资讯 > 地坪知识

    环氧地坪漆夏季施工VS冬季施工那个更好

    2019-07-01 16:13:07 无锡盛发地坪科技有限公司 阅读

    温度对环氧地坪漆施工有着重要的影响,关系着环氧地坪漆施工质量的好坏,温度过低会影响环氧地坪漆的固化时间和成膜效果,有可能造成漆膜硬度、强度、光泽度等性能下降;温度过高,则有可能导致环氧地坪漆表面出现麻点、针孔、粗糙、出现裂纹等。那么夏季高温和冬季低温进行环氧地坪漆施工有什么区别呢?环氧地坪漆厂家提醒大家:为了保证环氧地坪漆的施工质量和效果,一定要注意夏季高温和冬季低温施工环氧环氧地坪漆的区别。

    Temperature has an important impact on the construction of epoxy floor paint, which is related to the quality of the construction of epoxy floor paint. Low temperature will affect the curing time and film-forming effect of epoxy floor paint, which may cause the decline of film hardness, strength, gloss and other properties. High temperature may lead to the appearance of flax on the surface of epoxy floor paint. Points, pinholes, rough, cracks, etc. So what's the difference between high temperature in summer and low temperature in winter? The epoxy floor paint manufacturer reminds us that in order to ensure the construction quality and effect of epoxy floor paint, we must pay attention to the difference between high temperature in summer and low temperature in winter.

    1、夏季环氧环氧地坪漆施工时应该避免在上午11点到下午4点这段高温期,可以采用早晚时段分叉施工的方法,避免高温对环氧地坪漆施工的影响。冬季环氧地坪漆施工时则应该注意避开低温时间段,最好选在上午十点至下午三点施工,避免低温施工带来质量影响。

    1. The construction of epoxy floor paint in summer should avoid the high temperature period from 11 a.m. to 4 p.m. The method of bifurcation construction in the morning and evening can be used to avoid the influence of high temperature on the construction of epoxy floor paint. During the construction of epoxy floor paint in winter, attention should be paid to avoid the low temperature period. It is better to choose the construction from 10 a.m. to 3 p.m. to avoid the quality impact of low temperature construction. 2、夏季气温较高环氧地坪漆固化反应速度相对比较快,一般3-6个小时,地坪漆就会出现表面干化现象,整体施工时间可能会适当的缩短,如果局部需要休整,尽量在这个时间内完成,保证工程的整体质量。

    2. The curing reaction speed of epoxy floor paint is relatively fast when the temperature is higher in summer. Generally, surface drying will occur in 3-6 hours. The whole construction time may be shortened appropriately. If the part needs to be restored, the whole quality of the project can be guaranteed within this time.

    冬季气温较低,环氧地坪漆的固化时间延长,所以施工间隔也需要延长,要确定第一道工序中的底漆或中涂等干透再进行下一道工序。另外,由于环氧地坪漆越厚干燥时间越慢,因此在冬季施工要注意控制好每道地坪漆涂层的施工厚度,不要过厚。

    In winter, the temperature is low and the curing time of epoxy floor paint is prolonged, so the construction interval needs to be prolonged. It is necessary to make sure that the primer or intermediate coating in the first process is thoroughly dried and then the next process is carried out. In addition, because the thicker the epoxy floor paint, the slower the drying time, so in winter construction should pay attention to control the construction thickness of each floor paint coating, not too thick.


    3、夏季温度高,环氧地坪漆添加稀释剂应尽量采用慢挥发溶剂,混合甲乙组分时,采用少量、多次勤配的原则,防止出现涂料固化中放热过快的现象而引起涂料报废。

    3. When adding diluent to epoxy floor paint in high temperature in summer, slow volatile solvent should be used as far as possible. When mixing A and B components, the principle of a small amount and many times of diligence should be adopted to prevent the phenomenon of excessive heat release in curing of coatings and lead to the abandonment of coatings.

    冬季低温环境下环氧地坪漆粘度成倍增加,缺乏流动性,难以搅拌,使用之前要充分搅拌,适量添加挥发速率较快的溶剂,这样可以解决地坪漆在低温下黏度大,缺乏流平性的问题。

    Under the low temperature environment in winter, the viscosity of epoxy floor paint doubles, lacks fluidity, and is difficult to mix. Before using, it is necessary to mix fully and add solvent with a relatively fast volatilization rate. This can solve the problem of high viscosity and lack of leveling of floor paint at low temperature.


    标签:   环氧地坪 地坪 环氧地坪漆 环氧地坪施工 无锡环氧地坪
    无锡环氧地坪 技术支持:【易商科技】