欢迎光临无锡盛发地坪科技有限公司官网!【环氧地坪_防静电地坪_停车场地坪_耐磨地坪】材料生产,销售和施工的高新技术企业.

    示例图片三
    网站首页 > 新闻资讯 > 地坪知识

    环氧地坪漆粘度检测方法?是高好还是低好?

    2019-06-02 18:14:10 无锡盛发地坪科技有限公司 阅读

    环氧地坪漆粘度又可成为稠度,它是阻碍自己内部产生相对流动的一种特性。施工环氧地坪漆必须要保证环氧地坪材料有适当的黏度,可加入少量稀释剂以便达到理想黏度。施工方法不同,对环氧地坪漆涂料的稀释比例要求也不同。环氧地坪漆粘度大的四个因素:1、环氧地坪漆材料部宜在气温过低的环境下施工,如果当时气温过低的话会直接出现黏度大现象。2、在环氧地坪漆材料混合搅拌后,存放时间长,环氧地坪材料已反应就会发生黏度大现象。3、环氧地坪漆材料配料过程中加砂或加粉剂量过大,又没加溶剂从而导致黏度大现象。4、同比气温低当气温过高,环氧地坪漆材料可使用时间缩短后者就直接出现黏度大现象。

    The viscosity of epoxy floor paint can also become consistency, which is a property that prevents relative flow within itself. The construction of epoxy floor paint must ensure that the floor material has proper viscosity, and a small amount of diluent can be added to achieve the desired viscosity. Different construction methods require different dilution ratios of epoxy floor paint. Four factors of high viscosity of epoxy floor paint: 1. The Material Department of epoxy floor paint should be constructed in the environment of low temperature. If the temperature was too low at that time, the high viscosity would appear directly. 2. After mixing and stirring the epoxy floor paint material, the storage time is long, and the reaction of the floor material will lead to the phenomenon of high viscosity. 3. Excessive dosage of sand or powder and no solvent are added in the proportioning process of epoxy floor paint material, which results in high viscosity. 4. When the temperature is lower than that of the same year, when the temperature is too high, the viscosity of epoxy flooring paint will directly appear when the service time of epoxy flooring paint material is shortened. 

    环氧地坪漆粘度检测方法

    Viscosity Testing Method for Epoxy Floor Paint:

    1、环氧地坪漆对温度有一定要求,所以在测定涂料粘度的时候,要求温度控制在21~25摄氏度之间。温度过高或过低都测不出粘度的准确数值。

    1. Epoxy floor paint has certain requirements for temperature, so when measuring the viscosity of the paint, the temperature should be controlled between 21 and 25 degrees Celsius. If the temperature is too high or too low, the accurate value of viscosity can not be measured.

    2、测定粘度要多次测量取平均值,在每一次测量完之后要清洗-4杯。

    2. Measure the viscosity several times and take the average value. Clean - 4 cups after each measurement.

    3、测量时候,先用手或是工具将小孔漏嘴堵住,将100ml地坪漆倒满,然后在用玻璃棒将气泡和多余的式样放入凹槽,这样便可以保证测样不会超过标准。

    3. When measuring, first plug the orifice leak with hand or tool, fill the floor paint with 100 ml, then put the air bubbles and redundant patterns into the groove with glass rod, so as to ensure that the sample will not exceed the standard.

    4、最后,迅速将手指移开,并同时用秒表记录时间。

    4. Finally, move your finger away quickly and record the time with a stopwatch.


    环氧地坪漆施工粘度大解决办法

    Solution of high viscosity in epoxy floor paint construction:

    1、环氧地坪漆最佳施工温度为10-25℃,如果气温过低可以采取提高室内温度的方法。

    1. The optimum construction temperature of epoxy floor paint is 10-25 C. If the temperature is too low, the method of increasing indoor temperature can be adopted.

    2、减少混合搅拌后的存放时间,每次配料要在半小时之内施工完毕。

    2. Reduce the storage time after mixing and mixing, each batching should be completed within half an hour.

    3、减少砂的加入量,如果粘度大可以适当的添加稀释剂

    3. Reduce the amount of sand added, if the viscosity is high, appropriate diluent can be added.



    标签:   地坪 环氧地坪 环氧地坪漆 环氧地坪施工 无锡环氧地坪
    无锡环氧地坪 技术支持:【易商科技】