欢迎光临无锡盛发地坪科技有限公司官网!【环氧地坪】材料生产,销售和施工的高新技术企业.

    示例图片三
    网站首页 > 新闻资讯 > 地坪知识

    做出优质环氧地坪漆工程需要注意的地方

    2019-04-24 13:08:11 无锡盛发地坪科技有限公司 阅读

    做出优质的环氧地坪漆工程说难很难,说容易也非常容易,重要的是要了解环氧地坪漆施工工艺,注意施工过程中需要注意的几个环节。下面光磊环氧地坪漆厂家就给大家详细介绍做出优质的环氧地坪漆工程需要注意的几个环节。环氧地坪漆施工过程中需要注意的五个环节:

    It is difficult and easy to make high quality epoxy floor paint. It is important to understand the construction technology of epoxy floor paint and pay attention to several links in the construction process. The following Guanglei floor paint manufacturers will give you a detailed introduction to make high-quality epoxy floor paint engineering needs to pay attention to several links. Five links should be paid attention to during the construction of epoxy floor paint: 

    1、施工人员

    1. Construction personnel 环氧地坪漆厂家必须对各施工人员进行岗位技术培训,各施工人员应掌握熟悉环氧地坪漆施工工艺的各项技术指标及施工方法,绝对不允许盲目施工、野蛮操作,特别是面漆施工时,一定要有三年以上工作经验的。

    Floor paint manufacturers must carry out on-the-job technical training for all construction personnel. All construction personnel should be familiar with the technical indicators and construction methods of epoxy floor paint construction technology. Blind construction and brutal operation are absolutely not allowed. Especially when topcoat construction is carried out, they must have more than three years of work experience. 

    2、现场管理

    2. Field Management 必须同总包方及各分包单位进行良好的施工配合工作,必须对环氧地坪漆施工人员进行严格的现场管理并明确现场管理制度。

    Good construction cooperation must be carried out with the general contractor and subcontractors. The construction personnel of epoxy floor paint must be strictly managed and the site management system must be clearly defined. 

    3、基础地面

    3. Foundation Ground 好的基础地面是好的环氧环氧地坪漆涂装工作的保证,我们建议在地坪施工前由我们光磊地坪漆厂家的技术人员到现场进行指导施工,以免因基底效果不佳,而导致环氧地坪漆涂装效果不佳。

    Good base floor is a good guarantee for epoxy floor paint painting. We suggest that technical personnel from Guanglei floor paint factory should go to the site to guide the construction before the floor construction, so as to avoid the poor effect of the base and lead to poor coating effect of epoxy floor paint. 

    4、地坪漆材料

    4. Floor paint materials 必须严格检查、配置所用各项环氧地坪漆材料,所有进场材料都要进行检刚,杜绝不合格产品的使用。

    All kinds of epoxy floor paint materials must be strictly inspected and disposed. All incoming materials should be rigidly inspected to eliminate the use of unqualified products. 

    5、施工工具

    5. Construction tools 必须使用优质的滚、喷枪、漆刷、美纹纸等工具及辅助设备,避免因工具不良所导致的质量问题。

    We must use high quality roll, spray gun, paint brush, paper and other tools and auxiliary equipment to avoid the quality problems caused by poor tools. 

    进行环氧地坪漆施工时需要注意的事项

    Matters needing attention in the construction of epoxy floor paint: 

    1、使用前必须将地坪漆材料彻底搅拌均匀。

    1. Floor paint materials must be thoroughly stirred before use. 

    2、如地坪漆材料太稠,可适量加入天那水进行稀释搅拌均匀后再使用。

    2. If the floor paint material is too thick, it can be diluted and stirred with appropriate amount of Tianna water before use. 

    3、新铺水泥地面(最好用稀盐酸液洗刷一遍)应保证有50天以上的凝结干燥期,以免造成施工时返碱,致使漆膜变色脱落。

    3. New cement floors (preferably washed with dilute hydrochloric acid solution once) should be guaranteed to have a condensation drying period of more than 50 days, so as not to cause alkali return during construction, resulting in discoloration and peeling of paint film. 

    4、 水泥地面上有水泥渣等粘附物必须用铲子铲除,油污必须擦净清洗(可用合适溶剂如天那水),然后清扫干净。

    4. Cement slag and other adhesives on the cement floor must be removed with a shovel. Oil contamination must be cleaned (using suitable solvents such as Tiannao water) and then cleaned up. 

    5、如旧水泥地面有酯胶漆不宜使用环氧地坪漆。

    5. It is not suitable to use epoxy floor paint if there is ester paint on the old cement floor. 

    6、涂层不宜过厚,以免造成干燥慢、易起泡等问题。

    6. The coating should not be too thick to avoid the problems of slow drying and easy foaming. 

    7、施工环氧地坪漆应严格按施工配比,将主漆和固化剂充分搅拌均匀,然后加稀释剂搅拌均匀,过滤并放置大约15分钟进行施工,混合液需要在4小时内用完,以防止影响性能。

    7. Construction of epoxy floor paint should be strictly in accordance with the construction ratio, the main paint and curing agent should be fully stirred evenly, then add diluent to mix evenly, filter and put in about 15 minutes for construction, the mixture needs to be used up in 4 hours to prevent the impact of performance. 

    8、配好的环氧地坪漆在施工过程中会逐渐增稠,应适量加入稀释剂,以防出现流平性差,起泡的弊端。

    8. The prepared epoxy floor paint will gradually thicken in the construction process, and diluents should be added to prevent the disadvantages of poor leveling and foaming. 

    9、每遍涂装(尤其是厚装)必须等上一遍漆干透打磨后再涂,涂装间隔时间超过24小时应充分打磨彻底后再涂下一遍。

    9. Every painting (especially thick coating) must wait for the paint to be thoroughly polished before painting. The painting interval should be more than 24 hours after the painting should be thoroughly polished before painting again. 


    标签:   地坪 环氧地坪 环氧地坪施工 环氧地坪漆
    无锡环氧地坪 技术支持:【易商科技】