欢迎光临无锡盛发地坪科技有限公司官网!【环氧地坪_防静电地坪_停车场地坪_耐磨地坪】材料生产,销售和施工的高新技术企业.

    示例图片三
    网站首页 > 新闻资讯 > 地坪知识

    环氧地坪漆可以自己施工吗?怎么操作

    2019-03-18 12:12:10 无锡盛发地坪科技有限公司 阅读

    许多购买环氧地坪漆的消费者会有这样的疑问:环氧地坪漆施工难吗?环氧地坪漆可以自己施工吗?今天,环氧地坪漆厂家就给大家讲解环氧地坪漆是否可以自己施工。环氧地坪漆可以自己施工吗?可以自己施工,但是简单工艺可以,比如普通的环氧树脂平涂地坪工艺,价格也不是很高,就是适合普通的水泥地面。复杂的工艺或者地面很不平整的话,就不要自己施工,简单的工艺也盖不住,环氧地坪漆质量的好坏不单单和地坪漆材料的质量有关,施工手法也相当重要。施工要注意配比的方法和搅拌均匀,不然会引起地面不干的,买材料如果量大的话,会送工具,量小的话,工具也就十几块,不值钱,但是另算的。

    Many consumers who buy epoxy floor paint will have such questions: Is it difficult to construct epoxy floor paint? Can floor paint be constructed by themselves? Today, epoxy floor paint manufacturers will explain to you whether floor paint can be constructed by themselves. Can epoxy floor paint be built by itself? It can be built by itself, but simple technology can be, such as ordinary epoxy flat coating floor technology, the price is not very high, that is, suitable for ordinary cement floor. If the complex process or ground is very uneven, don't build it by yourself. Simple process can't cover it. The quality of epoxy floor paint is not only related to the quality of floor paint materials, but also the construction method is very important. Construction should pay attention to the method of mixing and mixing evenly, otherwise the ground will not dry, if the amount of material is large, tools will be sent, if the amount is small, tools will be more than a dozen, not valuable, but other. 

    二、环氧地坪漆施工方法:

    2. Construction method of epoxy floor paint: 1、素地处理

    1. Plain treatment ①基础素地以水泥粉光面或磨石地为准;

    (1) The basic plain ground shall be cement flour or grindstone ground; ②素地需养生28天以上,水份需8%以下方可施工素地如有不平或空鼓需加以除去;

    (2) The vegetable land should be kept in good health for more than 28 days, and the water content should be less than 8% before it can be removed if there is unevenness or empty drum in the construction of the vegetable land. ③用环氧砂浆补平地面;

    (3) Leveling the ground with epoxy mortar; ④素地之油污需澈底清洗干净;

    (4) Oil contamination of plain land should be cleaned thoroughly. ⑤施工前需保持施工素地之干燥和清洁;

    (5) Keep the construction site dry and clean before construction; 

    2、底涂层施工

    2. Construction of bottom coating ①施工前需保持干净如有杂物粘附需清除依照正确比例将主剂及固化剂混合,充分搅拌;

    1. Keep clean before construction. If there is any debris adhesion, remove the main agent and curing agent according to the correct proportion and mix them fully. ②需视地面情况调整适当粘度混合完成材料需4小时以内施工完成;

    (2) It takes less than 4 hours to finish the construction by adjusting the proper viscosity of the mixing material according to the ground conditions. ③底涂层养生硬化时间约8小时以上。

    Thirdly, the curing and hardening time of the base coating is more than 8 hours. 

    3、中涂砂浆层施工

    3. Construction of Middle-coated Mortar Layer ①施工前需要保持干净如有杂物粘附需清除依照正确比例将主剂及固化剂混合,充分搅拌;

    (1) Before construction, it is necessary to keep clean. If there is debris adhesion, it is necessary to remove and mix the main agent and curing agent according to the correct proportion and mix them thoroughly. ②将混合完成的树脂适量加入石英砂;

    (2) Quartz sand should be added to the mixed resin. ③使用镘刀将材料均匀涂布;

    (3) Apply the material evenly with a trowel knife; ④混合完成材料需30分钟以内施工完成;

    (4) It takes less than 30 minutes to complete the construction of the mixed materials. ⑤施工交接处做好交接处理;

    (5) Handover treatment should be done at the construction handover site; ⑥中涂层养生硬化时间约8小时以上。

    _The curing and hardening time of the middle coating is more than 8 hours. 

    4、中涂腻子层施工

    4. Construction of Middle-coated Putty Layer ①依照正确比例将主剂及固化剂混合,充分搅拌;

    (1) Mix the main agent and curing agent according to the correct proportion and mix them fully; ②将混合完成的树脂适量加入滑石粉,使用批刀将材料涂布均匀;

    (2) Added talc powder to the resin, and coated the material evenly with batch knife. ③混合完成材料需30分钟内施工完成;

    (3) It takes 30 minutes to complete the construction of the mixed materials. ④批土养生硬化时间约8小时以上;

    The hardening time of batch soil is more than 8 hours. ⑤视实际需要施工数道要求达到平整无孔洞,无批刀印及砂磨印为准。

    _Depending on the actual needs of the construction of several requirements to achieve flat without holes, no batch of knife printing and sanding printing shall prevail. 

    5、面涂层施工

    5. Surface Coating Construction ①施工前需保持干净如有杂物粘附需清除;

    (1) Keep clean before construction and remove debris if they stick to each other. ②使用前主剂先搅拌均匀;

    (2) The main agent should be stirred evenly before use. ③依照正确比例将主剂及固化剂混合,充分搅拌;

    (3) Mix the main agent and curing agent according to the correct proportion and mix them fully; ④使用滚筒或镘刀将材料均匀涂布,混合完成材料需30分钟以内施工完成;

    (4) The material is evenly coated with drum or trowel, and it takes less than 30 minutes to mix the material. ⑤施工交接处需做好交接处理;

    (5) Handover treatment should be done at the construction handover site. ⑥施工完成后,24小时后方可上人,72小时后方可重压(以250C为准,低温时开放时间需适度延长)

    _After the completion of construction, people can enter the building 24 hours later, and heavy pressure can be applied 72 hours later (based on 250C, the opening time should be prolonged at low temperature). 三、自己施工地坪漆注意事项

    3. Notes for Self-construction Floor Paint 1、施工温度≥5℃,若要在<5℃施工的,选用特殊配方。湿度建议在75%以下施工。

    1. Construction temperature (> 5 C), if construction temperature (< 5 C), select special formula. Humidity is recommended for construction below 75%. 2、施工时确保空气流通。调制使用量时,不能超过30分钟。

    2. Ensure air circulation during construction. The modulation dosage should not exceed 30 minutes. 3、施工过程做好保养工作,避免灰尘、杂物侵入,影响漆面效果。

    3. Maintenance work should be done well in the construction process to avoid the invasion of dust and sundries and to affect the paint effect. 4、施工完毕后,需养护至少7天方可投入使用。养护期间,特别不能有水或者各类溶液浸润。

    4. After completion of construction, maintenance is required for at least 7 days before it can be put into use. During the maintenance period, water or various solutions should not be infiltrated. 5、严禁混入其它油漆。

    5. It is strictly forbidden to mix other paints. 6、必须严格按照规定比例加入固化剂。

    6. The curing agent must be added strictly in accordance with the prescribed proportion. 7、保持被涂物表面的清洁,被涂物含水率必须小于7%。

    7. To keep the surface of the coating clean, the moisture content of the coating must be less than 7%. 8、保持涂装环境清洁,严禁在有大量灰尘的环境下施工。

    8. Keep the painting environment clean. It is strictly forbidden to construct in the environment with a large amount of dust. 



    标签:   环氧地坪 地坪 环氧地坪漆 环氧地坪施工
    无锡环氧地坪 技术支持:【易商科技】