欢迎光临无锡盛发地坪科技有限公司官网!【环氧地坪_防静电地坪_停车场地坪_耐磨地坪】材料生产,销售和施工的高新技术企业.

    示例图片三
    网站首页 > 新闻资讯 > 地坪知识

    解读环氧地坪漆的优点与缺点有什么

    2019-03-14 08:32:56 无锡盛发地坪科技有限公司 阅读

    环氧地坪漆是一种高强度、耐磨损、美观的地板,具有无接缝、质地坚实、耐药品性佳、防腐、防尘、保养方便、维护费用低廉等优点。可根据不同的用途要求设计多种方案:如薄层涂装,1-5mm厚的自流平地面,防滑耐磨涂装,砂浆型涂装,防静电,防腐蚀涂装等。

    Epoxy floor paint is a kind of high strength, wear-resistant, beautiful floor, with seamless, solid texture, good resistance, anti-corrosion, dust-proof, easy maintenance, low maintenance costs and other advantages. Various schemes can be designed according to different application requirements, such as thin coating, 1-5mm thick self-leveling floor, anti-skid and wear-resistant coating, mortar coating, anti-static, anti-corrosion coating, etc. 环氧地坪漆的优点:

    Advantages of epoxy floor paint:

    1、 整体无缝,完全不起尘,极易清洁,可满足高洁净度工业厂房的要求;

    1. It is seamless, completely dust-free, easy to clean, and can meet the requirements of high-cleanliness industrial plants.

    2、 颜色可任意选择、搭配,美观度极佳;

    2. The color can be chosen and matched at will, and the beauty is excellent.

    3、 防水、防霉、抗渗; 高度耐磨,可行走重型车辆;

    3. Waterproof, mildew-proof and impermeability-proof; highly wear-resistant, heavy-duty vehicles are feasible;

    4、具有较好的韧性,受到撞击不脱层、 不开裂;

    4. It has good toughness, no delamination and cracking when impacted.

    5、 与基层(混凝土、瓷砖、金属等)粘结牢固,在施工质量保证的前提下,不脱层、不开裂。

    5. It is firmly bonded to the base (concrete, ceramic tile, metal, etc.) without delamination or cracking under the premise of construction quality assurance.

    6、 耐一定程度的化学药品腐蚀。耐化学物质(酸碱甲醇)差。

    6. Resistance to chemical corrosion to a certain extent. Chemical resistance (acid-base methanol) is poor.


    环氧地坪漆的缺点

    Defects of epoxy floor paint:

    1、 不能抵抗较重的地下潮气:环氧地坪漆因其分子结构极为密实,地下潮气无法透过,若一楼地面混凝土基层未做防潮隔离层,则一旦地下潮气太重, 容易将环氧地坪涂层顶起,前期会形成一个鼓包,随后就会破裂、脱落。

    1. Unable to resist heavy underground moisture: epoxy floor paint because of its very dense molecular structure, underground moisture can not be penetrated. If the first floor concrete base is not made a moisture-proof isolation layer, once the underground moisture is too heavy, it is easy to top up the epoxy floor coating, which will form a bulge in the early stage, and then will burst and fall off.

    2、 抗划伤性能较差:环氧地坪漆涂层对于抵抗砂粒、铁屑等各类尖锐、坚硬物体的划伤能力较差。因此、施工环氧地坪漆的车间环氧地坪必须经常保持地面洁净。

    2. The scratch resistance of epoxy floor paint is poor: the scratch resistance of epoxy floor paint coating to various sharp and hard objects such as sand particles and iron chips is poor. Therefore, the floor of the workshop where epoxy floor paint is applied must always be kept clean.

    3、 耐高温性能较差: 一般环氧环氧地坪漆涂层的高耐受温度约为摄氏80度。 在某些车辆行走较为频繁的车间,当车辆的行驶速度过快时,一旦出现急刹车 或急转弯,则会因为急剧磨擦产生短时高湿使环氧地坪漆涂层变软,同时车辆轮 胎上的灰尘会渗入环氧地坪漆涂层内部,造成局部环氧地坪涂层擦伤、变色。此损坏部位以有机溶剂或其它清洗剂均无法彻底清除,唯一的解决办法是局部修补。

    3. High temperature resistance is poor: the high temperature resistance of epoxy floor coatings is about 80 degrees Celsius. In some workshops where vehicles travel more frequently, when the speed of the vehicle is too fast, once a sudden brake or sharp turn occurs, the epoxy floor paint coating will become soft due to short-term high humidity caused by sharp friction. At the same time, the dust on the tire of the vehicle will penetrate into the inner of the epoxy floor paint coating, resulting in local abrasion and discoloration of the epoxy floor coating. The damaged area can not be completely removed by organic solvent or other cleaning agent. The only solution is partial repair.

    4、 耐候性差:环氧地坪漆抗紫外线能力较差,不能长期应用于室外, 否则会加速老化,如变色、降低强度,甚至粉化、脱层等。环氧地坪漆材料易脆,耐老化性差、使用寿命短(平均3-4年) 所以要改善以上效果,可以把环氧树脂平涂地坪、环氧自流平地坪改成复配地坪:环氧树脂磨石地坪、环氧树脂彩砂地坪等。

    4. Weatherability is poor: Epoxy floor paint has poor anti-ultraviolet ability and can not be used outdoors for a long time, otherwise it will accelerate aging, such as discoloration, strength reduction, even pulverization, delamination, etc. Epoxy floor paint materials are brittle, poor aging resistance, short service life (average 3-4 years), so to improve the above effect, we can change the epoxy resin flat floor, epoxy self-leveling floor into composite floor: epoxy resin ground floor, epoxy resin coloured sand floor, etc.



    标签:   地坪 环氧地坪漆 环氧地坪 环氧地坪施工
    无锡环氧地坪 技术支持:【易商科技】