欢迎光临无锡盛发地坪科技有限公司官网!【环氧地坪_防静电地坪_停车场地坪_耐磨地坪】材料生产,销售和施工的高新技术企业.

    示例图片三
    网站首页 > 新闻资讯 > 地坪知识

    环氧地坪漆在地下室水泥地面的施工工序

    2019-02-23 21:59:49 无锡盛发地坪科技有限公司 阅读

    地下室环氧地坪漆怎么施工才能防尘美观大方??地下室施工环氧地坪漆后,能够起到无尘、美观。同时维护的方便也能够减少保洁员的工作量,这样就能减少些人力资源。但是很多的业主直接就是施工环氧地坪漆,出现了脱皮、起壳等现象。为此我们给出了以下两点建议供业主参考:

    How can the basement floor paint be constructed to be dust-proof and beautiful? After the basement floor paint is constructed, it can be dust-free and beautiful. At the same time, the convenience of maintenance can also reduce the workload of cleaners, which can reduce some human resources. But a lot of owners directly construct epoxy floor paint, there are peeling, shelling and other phenomena. For this reason, we give the following two suggestions for the owner's reference: 1、地下室地面见不到水汽,水泥地面下面防水做的很好,同时水泥地面的强度硬度达到了环氧地坪漆施工的要求,那么就可以施工一个环氧薄涂地坪漆。环氧薄涂地坪漆价格便宜,施工简单,工期短,施工完成24小时后就能投入使用。以下是环氧薄涂地坪漆施工:

    1. There is no water vapor on the basement floor. The waterproofing under the cement floor is very good. At the same time, the strength and hardness of the cement floor meet the requirements of the epoxy floor paint construction. Then an epoxy thin-coated floor paint can be constructed. Epoxy thin-coated floor paint is cheap, easy to construct, short construction period, and can be put into use 24 hours after completion of construction. The following is the construction of epoxy thin-coated floor paint:

    a、地面打磨,将地面打花一点,这样就能让环氧底漆与水泥地面之间的粘结力加强,不容易出现环氧地坪漆涂层起皮,起壳,很多环氧地坪漆起皮脱壳就是底漆与水泥地面间的粘结力不足导致的。

    A. Ground polishing and flooring, so that the bond between epoxy primer and cement floor can be strengthened. It is not easy for epoxy floor paint coating to peel and shell. Many of the peeling and peeling of epoxy floor paint is caused by the insufficient bond between primer and cement floor.

    b、滚刷明诚牌特制的环氧底漆,针对不同的水泥地面,采用明诚地坪漆公司特制的底漆进行施工,粘结力才好。将A组分及B组份按照一定的重量比倒入到配料桶中,使用搅拌枪将其搅拌均匀。注意:一定是按照重量比来配料,同时一定要搅拌均匀。很多时候客户自己配料没有按照这两条来,导致油漆不干燥。

    B. Roll-brush special epoxy primer of Mingcheng Brand. According to different cement floors, the primer made by Mingcheng Floor Paint Company is used for construction, and the bonding force is good. Component A and component B are poured into the batching barrel according to a certain weight ratio and stirred evenly with a stirring gun. Note: It must be proportioned according to the weight ratio, and must be stirred evenly at the same time. Many times, customers do not follow these two ingredients, resulting in non-drying paint.

    c、待明诚环氧底漆干燥后,将明诚环氧中涂按照一定的重量比搅拌均匀,使用刮刀将其均匀的批刮在地面上。d、环氧中涂干燥后,打磨除尘,然将明诚环氧面漆按照一定的重量比搅拌均匀,使用滚筒将面漆滚刷在地面上。注意:这个要根据现场的施工人员来配料,防止施工人员滚刷不过来导致材料烧掉。

    C. After the Mingcheng epoxy primer is dried, the Mingcheng epoxy primer is mixed evenly according to a certain weight ratio, and scraped evenly on the ground with a scraper. D. After the epoxy coating is dried, polish and dust removal, then mix the Mingcheng epoxy topcoat evenly according to a certain weight ratio, and roll the topcoat onto the ground with a drum. Note: This should be based on the site of the construction workers to ingredients, to prevent the construction workers can not roll over and cause material burning.

    2、如果地下室有水汽上涌,那么就不能施工环氧地坪漆,必须采用混凝土密封固化剂地坪来施工。混凝土密封固化剂地坪能提高混凝土地面的抗压强度;紧缩混凝土毛细孔,有效抑制外界污染物进入混凝土;能抵抗氯化物及其他化学物质的侵蚀;和基层混凝土中的物质发生反应在其毛孔中形成一种胶体;密封混凝土,增强其密度;有较高的的抗渗性和抵御油脂的性能;处理后的地面会出现大理石般的光泽,使用越久光洁度越好。

    2. If there is water vapor upwelling in the basement, then the epoxy floor paint can not be constructed, and the concrete sealant curing agent floor must be used for construction. Concrete sealant and curing agent floor can improve the compressive strength of concrete floor; shrink the capillary of concrete, effectively inhibit the entry of external pollutants into concrete; resist the erosion of chloride and other chemical substances; react with the substances in the base concrete to form a colloid in the pore; seal concrete, enhance its density; have higher impermeability and resist grease. Performance; After treatment, the ground will appear marble-like luster, the longer the use of the better finish.

    3、地下室水泥地面起砂起粉,有轻微的水汽,可以采用环氧砂浆滚涂地坪。环氧砂浆地坪耐磨性好:采用特殊的矿物做为填料,经久耐磨,特别坚固。装饰性能及佳。

    3. Basement cement floors are sanded and powdered with slight water vapor. Epoxy mortar can be used to roll-coat the floors. Epoxy mortar floor has good wear resistance: special minerals are used as fillers, durable and wear-resistant, especially strong. Decorative performance and good.


    标签:   环氧地坪 地坪 环氧地坪漆 环氧地坪施工
    无锡环氧地坪 技术支持:【易商科技】