欢迎光临无锡盛发地坪科技有限公司官网!【环氧地坪_防静电地坪_停车场地坪_耐磨地坪】材料生产,销售和施工的高新技术企业.

    示例图片三
    网站首页 > 新闻资讯 > 地坪知识

    环氧地坪涂装粗糙的由来及解决方法

    2019-02-02 22:11:57 无锡盛发地坪科技有限公司 阅读

    一、施工环境和环氧地坪漆膜干燥过程中的环境不干净,灰尘多,使灰尘落在还处于流平阶段的漆膜上,最终导致灰尘黏附于环氧地坪漆涂膜上而使涂膜出现粗糙现象。二、环氧地坪涂料涂装前没有过滤,混入机械杂质,这些机械杂质与涂料一起被涂装在了被涂物上,当涂膜干燥后机械杂质就突显在环氧地坪漆涂膜上了,最后导致涂膜出现了粗糙的现象。三、由于环氧地坪涂料是双组分或多组分涂料,又属于化学固化型涂料,所以当涂料混入固化剂后,涂料就开始起化学作用,环氧地坪涂料黏度就慢慢升高,到特定时间后就开始胶化,直接最后固化成膜。当涂料开始胶化仍继续施工时,地坪漆涂膜就可能出现粗糙了。

    1. The construction environment and the drying process of the epoxy floor paint film are not clean and dusty, which makes the dust fall on the film which is still in the leveling stage, and eventually causes the dust to adhere to the floor paint film and make the film rough. 2. The epoxy floor coatings were not filtered before painting, and were mixed with mechanical impurities. These mechanical impurities were coated on the coatings together with the coatings. When the coatings were dried, the mechanical impurities were highlighted on the floor coatings, which eventually led to the appearance of rough coatings. 3. Because epoxy floor coatings are two-component or multi-component coatings, and belong to chemical curing coatings, when the coatings are mixed with curing agents, the coatings begin to play a chemical role, and the viscosity of epoxy floor coatings increases slowly. After a certain time, the coatings begin to gelatinize and then solidify directly into films. When the coating begins to gelatinize and continues to be applied, the film of floor paint may be rough.

    四、施工现场温度太高,稀释剂挥发太快,环氧地坪漆涂料涂到被涂物上已经没有流平的时间就已经开始固化,因此就会出现粗糙的现象。

    Fourth, the construction site temperature is too high, the diluent volatilizes too fast, the epoxy floor paint coated on the coating has no leveling time has begun to solidify, so there will be rough phenomenon.

    环氧地坪施工易被忽略的环节

    Neglected links in epoxy floor construction

    环氧树脂地坪,不仅可以保护混凝土地面,还可以提高地坪表面的耐磨抗重抗压性能,还能达到装饰美观、净化无尘车间的效果。

    Epoxy resin floor can not only protect concrete floor, but also improve the anti-wear, anti-weight and anti-compression performance of the floor surface. It can also achieve the effect of beautiful decoration and clean dust-free workshop.

    环氧树脂地坪的厚度很薄,它要承载表面的所有重压,主要还是靠地坪基面来支撑,地坪基面的质量就是环氧树脂地坪质量的重点。

    The thickness of epoxy resin floor is very thin. It bears all the heavy pressure on the surface. It is mainly supported by the base of the floor. The quality of the base of the floor is the focus of the quality of the epoxy resin floor.

    而基面的质量问题往往是很多人不重视的问题,甚至还常出现因忽视地坪漆基面的处理,而造成工程的质量隐患。

    The quality of the base surface is often a problem that many people do not pay attention to, and even often there is a hidden quality hazard caused by neglecting the treatment of the base surface of floor paint.

    下面因忽视地坪基面处理而造成工程质量隐患的几个原因:

    Following are several reasons for the hidden danger of engineering quality caused by neglecting the treatment of ground surface:

    1、甲方。甲方认为既然是混凝土地面弄好后,再在上面施工环氧地坪漆,那混凝土地面就不用太注重质量,差一点都无所谓。

    1. Party A. Party A considers that since the concrete floor is finished and epoxy floor paint is applied on it, the concrete floor need not pay too much attention to quality, which is almost indifferent.

    2、地坪基面施工队。地坪基面施工队认为,反正基面处理后会用环氧地坪漆盖住,有点小问题甲方也看不出来,随便弄就行。

    2. Floor foundation construction team. The construction team believes that the ground surface will be covered with epoxy floor paint after treatment anyway. Party A can't see any minor problems, just do it anyway.

    3、环氧地坪漆施工方。环氧地坪漆施工方对基面认识不足,与甲方沟通中未表达对基面的要求,施工中也不注意。或者同行竞争严重,再差的地坪基础都接,做好收完款走人。导致人们对基面的重视意识越来越淡薄。

    3. Construction side of epoxy floor paint. The Construction Party of epoxy floor paint does not know enough about the base surface, and does not express the requirements for the base surface in communication with Party A, nor does it pay attention to the construction. Or peer competition is serious, no matter how poor the foundation of the floor is, do a good job of collecting money and leaving. As a result, people's awareness of the importance of fundamentals is becoming weaker and weaker.

    作为专业的地坪漆生产厂家,混凝土基面处理不好,会导致环氧地坪漆的使用质量和使用年限下降,地坪漆弊病产生的几率增加,甲方在使用环氧地坪漆的过程中会需要频繁的返修。不停的影响使用体验,和影响生产。对混凝土地面施工队来说,最终追溯责任,还是要找到混凝土基面的施工方,最终仍是难逃责任。对地坪漆施工方而言,频繁返修,消费的人力精力,并持续增加成本,会成为一个巨大的负担。

    As a professional floor paint manufacturer, poor treatment of concrete base will lead to the decline of the quality and service life of epoxy floor paint, increase the probability of floor paint defects, and Party A will need frequent repairs in the process of using epoxy floor paint. Continuously affect the use of experience, and affect production. For the concrete ground construction team, the ultimate retrospective responsibility, or to find the construction side of the concrete foundation, is still the ultimate responsibility. For floor paint builders, frequent repairs, consumption of human energy, and continuous increase in costs, will become a huge burden.

    所以,在涂装环氧树脂地坪工程时,混凝土基面的质量,环氧涂层施工的质量都是工程的关键,不管是哪个环节出了问题,完工后的工程质量都会大打折扣。

    Therefore, the quality of concrete base surface and the quality of epoxy coating construction are the key points in the epoxy floor coating project. Whatever link is wrong, the quality of the finished project will be greatly reduced.

    因此:地坪漆施工方一定要注意混凝土基面的处理。

    Therefore, the floor paint construction party must pay attention to the treatment of concrete base. 


    标签:   环氧地坪 地坪 环氧地坪漆 环氧地坪施工
    无锡环氧地坪 技术支持:【易商科技】