欢迎光临无锡盛发地坪科技有限公司官网!【环氧地坪_防静电地坪_停车场地坪_耐磨地坪】材料生产,销售和施工的高新技术企业.

    示例图片三
    网站首页 > 新闻资讯 > 新闻资讯

    离心风机维护修理人员必须注意行业标准

    2018-12-20 08:48:55 无锡盛发地坪科技有限公司 阅读

    为了避免由于维护不当而引起人为故障的发生,预防离心风机及电机各方面的自然故障及事故的发生,从而充分发挥设备的性能,延长设备的使用寿命,必须加强离心风机的维护。

    离心风机维护人员必须注意下列各点:

    1、只有在离心风机设备完全正常情况下方可运转。

    2、如离心风机设备在检修后开动时,则需注意离心风机各部位是否正常。

    3、定期清除离心风机及气体输送管道内部的灰尘、污垢及水等杂质、并防止锈蚀。

    4、对离心风机设备的修理,不许在运转中进行。

    In order to avoid human fault caused by improper maintenance and prevent natural faults and accidents in various aspects of centrifugal fan and motor, so as to give full play to the performance of the equipment and prolong the service life of the equipment, it is necessary to strengthen the maintenance of the centrifugal fan.

    Centrifugal fan maintenance personnel must pay attention to the following points:

    1, only under the condition that the centrifugal fan equipment is completely normal.

    2, if centrifugal fan equipment starts after maintenance, attention should be paid to whether the parts of the centrifugal fan are normal.

    3. Regularly remove impurities, dirt and water from centrifugal fans and gas pipelines, and prevent rust.

    4. Repair of centrifugal fan equipment is not allowed in operation.

    离心风机正常运转中需要的注意事项如下:

    1、如发现流量过大,不符合使用要求,或短时间内需要较小的流量,可利用节流装置进行调节。

    2、对温度计及油标的灵敏性定期检查,并应控制轴承箱油位在规定的允许范围内。

    3、在离心风机的开车、停车或运转过程中,如发现不正常现象时,应立即进行检查。

    4、对检查发现的小故障,应及时查明原因,设法消除或处理,如小故障不能消除,或者发现大故障时,应立即进行检查。

    5、除每次拆修后,应更换润滑油外,还应定期更换润滑油。

    6、对E式传动的轴承座应定期(季度)检查,清洗和补加润滑油,以防轴承烧坏。

    The following points for attention in the normal operation of centrifugal fans are as follows:

    1, if the flow is too large, does not meet the requirements of use, or need less traffic in a short time, the throttle device can be adjusted.

    2. Periodically check the sensitivity of the thermometer and oil standard, and control the oil level of the bearing box within the prescribed allowable range.

    3. During the start-up, shutdown or operation of centrifugal fans, any abnormal phenomena should be checked immediately.

    4. To check and find out the small faults, we should find out the reasons in time, try to eliminate or deal with it, such as the small fault can not be eliminated, or when a big fault is found, it should be checked immediately.

    5, in addition to each demolition, should be replaced with lubricating oil, should also be replaced regularly.

    6, E type transmission bearing block should be checked regularly (Ji Du), cleaning and adding lubricating oil to prevent bearing burn out.

    辛苦整理!转载请注明来自 http://www.wxmlfj.com/faq/124.html



    标签:   离心风机 环氧地坪 地坪 环氧地坪漆 环氧地坪施工
    无锡环氧地坪 技术支持:【易商科技】