欢迎光临无锡盛发地坪科技有限公司官网!【环氧地坪】材料生产,销售和施工的高新技术企业.

    示例图片三
    网站首页 > 新闻资讯 > 环氧地坪

    环氧地坪施工质量有哪些要求?

    2018-11-09 13:48:46 无锡盛发地坪科技有限公司 阅读

    环氧地坪漆施工有着严格的施工要求,看似简单,实际上完成一个高质量的环氧地坪,是需要繁多的工序的。环氧地坪漆施工的项目越较大,工期就会越长,相对的也会有很多外界的因素影响着工程进度。同时,优质涂料若不采用先进的施工工艺不会得到优良的效果,因此施工对于环氧地坪漆来说是非常重要的。

    The construction of epoxy floor paint has strict construction requirements. It seems simple. In fact, to complete a high quality epoxy floor paint requires a lot of processes. The larger the project of epoxy floor paint construction is, the longer the construction period will be. Relatively, there will be many external factors affecting the progress of the project. At the same time, high-quality coatings will not achieve good results without the use of advanced construction technology, so the construction of epoxy floor paint is very important. 

    基材表面平整的影响:基材表面平整度即是指表面的凹凸的程度。我们一般选用2m的靠尺测量其缝隙的间距,在3mm以下都算是平整度较好的。

    Substrate surface smoothness: substrate surface smoothness is the degree of surface concavo convex. We usually use 2m's ruler to measure the spacing of the gaps, and below 3mm is a good flatness.

    地面处理方案:

    Ground treatment plan:

    1.新地面工程最好有磨平处理。

    1. the new surface works should be handled well.

    2.除油污、旧油漆。

    2. oil and old paint.

    3.长坡度填补不平整地面。

    3. long slope to fill uneven ground.

    4.地面必须进行干燥处理。

    4. drying must be carried out on the ground.

    5.修补损坏区域。

    5. repair damaged area.

    外界环境因素影响:环氧地坪漆对施工环境的温度条件要求较高,不能在过低或过高的温度下施工。

    Influences of external environmental factors: Floor paint requires higher temperature conditions of construction environment, and can not be constructed at too low or too high temperature.

    温度对环氧地坪漆施工的影响:环氧地坪漆中,双组分的涂料在温度低于5度的环境中很难进行固化反应,或者反应非常慢,从而导致成膜的时间大幅延长,或者导致无法成膜,无法固化。

    The influence of temperature on the construction of epoxy floor paint: In epoxy floor paint, it is difficult for two-component paint to cure under 5 degrees, or the reaction is very slow, which results in a considerable extension of film forming time, or leads to the failure of film forming and curing.

    不仅如此,灰尘等杂物很容易污染其表面造成装饰性效果变差。同时,还会影响涂膜的性能,使其硬度降低、耐磨性变差等,从而直接就影响了环氧地坪的使用寿命。

    Not only that, dust and other debris easily pollute the surface, resulting in poor decorative effect. At the same time, it will also affect the performance of the film, make its hardness lower, wear resistance worse and so on, thus directly affecting the service life of the floor.

    湿度对环氧地坪漆施工的影响:根据环氧地坪漆施工要求规定,当空气相对湿度高于85%时,是不能进行环氧地坪漆施工的,因为容易出现泛白、裂纹等弊病。专业工程中心认为,在湿度指数过大的情况下进行环氧地坪漆的施工,会引起涂装表面结露,凝结的水会对固化剂造成破坏引起涂膜发白、失光、发黏、回黏等现象,大大降低表面装饰效果.

    The influence of humidity on the construction of epoxy floor paint: According to the construction requirements of epoxy floor paint, when the relative humidity of air is higher than 85%, the construction of epoxy floor paint can not be carried out, because it is prone to white, cracks and other defects. Professional Engineering Center believes that the construction of epoxy floor paint under the condition of excessive humidity index will cause dew on the surface of the coating. Condensed water will damage the curing agent and cause the phenomenon of whitening, losing gloss, sticking and sticking back of the coating, thus greatly reducing the decorative effect of the surface.


    标签:   环氧地坪 地坪 环氧地坪漆 环氧地坪施工 环氧地坪翻新
    无锡环氧地坪